Ford 6.0L Power Stroke Diesel :: 2003 - Exhaust Smell In Ventilation System When Romps On The Pedal
Mar 4, 2015
Usually in the OBS 7.3 but a buddy of mine with a 2003 6.0 is having some issues. When he romps on the pedal but when he does so he claims he can smell exhaust in the ventilation system. I rode with him and smelt it as well. So I inspected all exhaust clamps and piping as best I could and did not notice any soot or leaks while running. I don't know if it pertains to it or not but his heater only works on defrost.
View 4 Replies
Advertisement
I have an exhaust smell in the cab of the truck. It is pretty strong. Seems worse when it is really cold outside and goes away when outside temps warm up. I checked the tube (passenger side behind engine) and did not see any soot.
View 12 Replies
Was cold this morning, -15c, and I remote started the truck and then left home about 5min later. I could smell exhaust in the cab. I read some of the other threads about this. How can I tell if it was doing a regen? I have an Edge Insight. Is the a parameter I can display to know the regen was active?
View 14 Replies
Got to thinking today while my truck was warming up, why does the exhaust smell so bad. I think it is kinda interesting that the exhaust pipe is so clean also, like new matter of fact.
So what make the exhaust smell? The exhaust filter traps the partials right but where did the diesel smell go? I can understand it when in regen but in normal operation I don't get it. I guess I just don't the mechanics behind it. All I do know is that, what is left just stinks especially when warming up.
View 12 Replies
We've had a run of -20 to -40 weather here for the past few weeks.
A few weeks back I noticed that when I climbed into my truck after command-start warm up for 10 minutes, and I could smell strong exhaust.
I figured it was hopefully the wind, or an isolated event.
Over the past few weeks I've used my truck for 3-4 more around town runs and every time I warm it up I get the strong exhaust smell. It's that rich, eye watering, sickening exhaust smell. I also notice a small yellow frozen puddle under the exhaust tips that wasn't there before.
It's bad in the cab, but even walking around outside the truck and the smell is sickening. I actually just started the truck and I could actually smell the exhaust smell faintly, from inside my house! This has never before occurred. Prior to this, a person could hardly tell it was a diesel by the smell of the exhaust.
Once the truck is up to temperature the smell seems to disappear, or at least lessen.
View 14 Replies
Started smelling exhaust in the cab while idling, and at startup. After further investigating found out the EGR inlet tube is leaking at the flex joint. So my question is , is there anything that will jump at me while I'm doing this tube replacement.
View 3 Replies
2015 6.7 KR... when idling for long periods of time the cab starts to smell like exhaust. I've also noticed when standing outside the truck with it idling (not in regen), it freaking stinks, bad! My 2003 never had this problem and idled for days (literally). Possibly leaky gasket here or just the nature of the 6.7?
View 14 Replies
I just took my new (to me) 2012 F350 out for it's first real tow job; pulled our 9,500lb travel trailer up and over the Sierra Nevada Mountains for a week long camping trip.
Under load, I started to smell a burning metal/paint smell in the cab, to the extent that I was wondering if something was wrong. All of the gauges were fine, and there was no unusual smell under the hood.
My wife discovered the floor on the passenger side was hot to touch (directly above the exhaust), and it actually started to melt a few plastic items in her purse.
I did just have the EGR valve replaced after it threw a code; not sure if there's some coating on the new one that could be burning off.
Isit normal for the floorboard to be that hot when working thes trucks?
View 14 Replies
I have been smelling a slight exhaust smell in the cab of the EX. I slide under the truck and looked at the up pipes and bellows. I saw a slight amount of soot on the outside of both bellows. So does that mean I have a leak? What is the most economical fix? Does the turbo need to be removed?
View 4 Replies
My check engine light just came on and a few miles later the "exhaust fluid system fault" also came on. I plugged in my scanner and these codes came up:
P2479 b1s2
P2033 b1s2
P050E
P0231 b1s2
I'm assuming these mean bank one sensor 2 is bad. Need to verify? I don't remember all these codes when the #4 sensor went bad.
View 8 Replies
Today I drove to dinner in my 2012 6.7 with no problems then on the way home my brother said he noticed my truck was white smoking quite a bit and he said there was a very strong exhaust smell coming from my truck ( he was in his car behind me) I ran a diagnostic test and what came up was code P0401 (I believe that's right). Need to figure out what is going on with my truck before I take it to the mechanics and get charged up. The truck still has DPFs in it just has a DPF back exhaust and has a AFE cold air intake running on a stock tune. However I do have the DPF deletes and EGR delete sitting in my garage just haven't gotten them on the truck yet.
View 2 Replies
I had a ford technician plug in and check my CEL. Says P246E, Bank 1 sensor 4, exhaust system fault. I am leaving for holidays in a couple of days but dealer to busy before I leave. Is this something that will leave a guy stranded on the side of the road? I've already been towed once...
View 5 Replies
2014 F250 Diesel... I got the msg saying 50 miles until speed limited to 50 mph. None of the earlier warnings re adding def. check def on computer and it said it was ok. I even added def and it only took a small amount until it overflowed. It was more than 1/2 full. The error message did not reset. I drove it around for several miles and it still would not reset. Having it services as we speak, and the tech is still having difficulty running down the cause. He has done a regen,and reset the computer and etc and still has not resolved the issue..
View 14 Replies
I bought my 2015 F250 last November, and this spring my check engine light comes on with the message exhaust system fluid fault with the anoyying speed limitation. Bring the truck back to the dealer and they just say add def fluid, so I just have them do it. 2 weeks later the message comes back, bring it back to the dealer and they tell me it "needs reprograming" they do the work, light goes off. two weeks later light comes on again. Dealer puts in new exhaust sensors and reprograms the truck.
This fix lasts a few months in the mean time the truck shutters really bad under regeneration mode. Talk to dealer they claim its normal. Finally this week the light comes back on again. Bring the truck to the dealer and Ford keeps telling them that it only needs reprograming but that doesn't fix the problem. The dealer wants to replace the computer but ford isn't letting them do it (the truck is still under warranty) . I am starting to get pretty mad when I went out and bout a 65k truck not to have these problems.
View 6 Replies
In the last year I've had a NOX sensor fault (dealer repaired) and a DEF heater fault (I replaced). I'm now getting an EGT sensor fail. Every fault is with the same system.
I'm also realizing that while I'm getting the exhaust system cleaning message, my DEF level is not being depleted.
All the dealership wants to do is change out fault codes but I think the true issue is elsewhere.
2011 F250 SD FX4 6.7L (stock)
View 4 Replies
'05 1.8T with 30K miles: Sometimes, when the car is stopped and idling, an oil burning kind of smell comes in through the ventilation system. I can also smell it outside. I had the dealer (a good one) check it out. Couldn't find anything. No sign of leakage anywhere. Where I or they should be looking? When I open the hood during these smell events, I can't see any smoke or tell exactly where it's coming from. It seems to be around the driver's side of the engine, but all the heat is on the other side around the exhaust and turbo. Weird. It's really starting to annoy me.
View 3 Replies
I'm having an issue with massive oil consumption and no oil leaks on the ground! No clue where the oils going but I burned more than 2 gallons today in a few hours of driving exhaust smells awful but the truck is running fine.
View 14 Replies
My 2012 F350 Lariat has 6100 miles on it now and on the way home tonight I got a "speed limited to 50 mph in 50 miles" message on the display. It states that there is a "diesel exhaust fluid system fault". The def was topped off about 2000 miles ago and the message center says that the fluid level is "ok". I am going to be on the phone with the dealer first thing in the morning. This is my personal/work truck and if I can't tow a trailer then I can't work. My guess would be a faulty sensor. I have no doubts that the dealer will get this resolved quickly as they have been great about everything else. I also want to say that other than this, I am sure minor issue, this truck is awesome!
View 14 Replies
I just installed a new MBRP 5'' exhaust system in my 7.3. I have only put a few miles on the truck since it was installed and I now have a black thick oily residue in the tailpipe. The exhaust system had some sort of oil in it when it was shipped. I remember getting it on my hands when installing it. I think the oil in my tailpipe is just the oil burning out of the exhaust system which mixes with soot that turns it black. When I installed the new up-pipe, the exhaust side of the turbo was dry. Like I said, I haven't ran the truck many miles with the new system yet. A few friends of mine have looked at the exhaust and they think I have a bad turbo seal. I didn't have any oil in the exhaust with the old system. It was sry. My truck has 135,000 miles on the original turbo. I hope my turbo seals aren't bad.
View 7 Replies
2002 Excursion 4x4 7.3 PSD 90,000 miles Hydra Tuner
the past few days I started smelling diesel fumes in the cab of my truck with bent on and also at the front of the truck when installing new bumper and winch. It's not real strong in the cab but pretty stout at the bumper. I have poped the hood and made a quick visual inspection and from underneath the only evidence of any leak is some power steering fluid which is a different issue (I think)
a week or 2 ago I was cleaning the Ex and noticed 2 or 3 drops of red fluid on the concrete under the Ex I crawled under and looked up and the steering knuckle was pretty wet. Popes the hood and took a look from the top and the power steering pump was sticky and dirty but the only fluid was on the top of the cap.. I'm not real familiar with the set up on the Ex but I have heard the PS support the break booster. From visual inspection it seems as though the fluid is coming they the small (vent?) hole on the cap. What I can/need to do to stop this?
View 12 Replies
I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?
View 14 Replies
