Focus :: 2004 Ford Stall Only Moments After Engine Turn On / Fuel Ceased
Feb 9, 2016
I have a ford focus (2004) 4cyl 2.0 L. One day, the car would stall only moments after the engine would turn. It would just shut as if fuel was ceased. I could however rev the engine and keep it running if I had my foot on the gas. After awhile, I tried again and it worked! Everything was normal, then it stalled after trying to start if up again. So this was intermittent at the time.
So, I swapped my fuel pump relay with the a/c one- and it fired right up! I'm thinking great, its just the relay and not the actual fuel pump. So went to the parts store, got a relay, and (me being me) wanted the new relay in the original fuel pump relay plug in the fuse box. As I was taking it out, a really really small piece of plastic chipped off of the plastic cover of the relay, and fell in one of the slots where you put the relay. How in the world?? I couldn't get it out. So I ended up putting the relay in anyway, and my car has the same problem originally (stalls), but now I have these check engine codes: p0460 and p0463
I also noticed, its running really rough when I hold the gas now. Could the plastic piece that fell into the relay be causing a strange short from my fuse box? Or, could it be my fuel pump this whole time? If its messed up because the plastic, Is finding a fuse box at a junkyard and replacing it feasible?
View 2 Replies
Advertisement
2004 Ford Focus, 2 Liter Zetec engine.0. Situation: Car initially running well but want to improve mileage, so I installed premium plugs.1. Ran roughly on test run, so headed home. Check Engine light came on before fully warmed up.2. Found and corrected loose plug wire.3. Engine now purrs like a kitten, but Check Engine light stays on.
What should I do now?
View 8 Replies
So this morning I was in rush hour traffic, stopped at a traffic light when all of a sudden, I get the bong that signals "refuel" I have just under 1/2 tank, though. Glanced down at the fuel gauge to see it drop down to E and then a few moments later back up to just under 1/2. All the will car was running and seemed fine otherwise. The refuel sign stayed on though ...... even when switched off (while MFD was still on) Restarted the car and refuel message was no longer displayed. What could this be? fuel pump on the way out?
View 24 Replies
When start my car and turn on the lights, its on for a few moments and they flicker, and then the driver side turns off. I toggle the switch off and on, and they fire right back up, but few moments later its off again. After about 10 minutes of doing that, they usually stay on, but once I make a quick stop (at store or bank for example) and turn off the headlights, the issue starts again and I usually cant get them to stay on after that unless I park the car for a few hours, and go through the 10 mins of screwing around with them again. Sometimes it will cause the passenger side to turn off as well, or sometimes even both!
I really need to fix this, along with my front parking lights in the bumper and the rear side bumper lights as well. I also have to take care of my license plate lights, which the harness does not even seem to be there behind the left lens, and the right one is missing.
I want to fix them, but if I take apart the fixtures, I want to polish the inside of the lens. and do any other mods at that time. I want to stick with the HID's, but maybe get some different bulbs for the low beam, that funky yellowish light that runs during the day, and the fog lights. I am not going to mess around with the LED's for a while. I had halogens in my last car that I had to update to HID to get good light, and these SC lights are even better since they are auto leveling, and turn with the car for the most part as well.
Does this sound like the bulbs? I heard of people online changing the bulbs and still having this issue. I thought it could be ballasts, but I am a newbie to the HID lighting so I am not sure. There are youtube vids up with this issue on the SC and ES models also I believe, so this is a known problem that pops up for everyone at one point during ownership.
View 9 Replies
2012 Ford Focus, 115 000 miles. Starting issues. A few weeks ago I would turn the key in the ignition and there would be nothing for about 3 or 4 seconds and then it would turn over. Now it does not turn over at all sometimes. Sometimes it starts right up and other times it does not. The lights on the dashboard still come on but it just does not turn over. Loose connection somewhere? Starter relay? Battery?
View 1 Replies
I recently installed a cold sensor to my 2002 ford focus due to it trying to stall out in cold weather. It is still trying to stall out even with the cold sensor what else could be the problem?
View 2 Replies
I've replaced the fuel pump, relay, drive module, and the filter. The fuel pump still refuses to switch on when I go to start the vehicle.
View 9 Replies
I have a 2004 Prius and in 2007 my center display ceased to work. I had my local Toyota dealership replace it. Well low and behold it is shot again. There is a picture display but the touch buttons do not work. I called Toyota again to see if the price has come down. Apparently in 2007 when my display was replaced it was replaced with a refurbished one and mine was sent to a company who refurbishes these units. I was told this process no longer exits and I would have to purchase a new unit from Toyota. I haven't done it. I am using the controls on the steering wheel. How to resolve this?
View 2 Replies
My Focus has 102,000 miles. It has thrown a p0171 code and I have been attempting to fix it. So far this is what I have done:Changed MAF, air filter, PCV Valve, plugs, Valve cover gaskets, Bank 1 O2 sensor and fuel filter. All new. I have cleaned the throttle body, fuel rail intake manifold. Cannot hear vacuum leaks and tested for leaks with carb cleaner.
Symptoms: engine cranks but has a hard time starting, usually on second try. When tank is about half full I get Rough acceleration, higher RPMs (doesn't change gear) and engine stalls on hard left turns. Idle gets rough at times but usually stabilizes at around 700 rpms.
At the beginning, #1 spark plug chamber had a lot of oil in it. It's been a few months and no oil after Valve cover gasket and PCV change. Tested coils and the plugs get a spark. Before I start messing with the fuel pump, am I missing something else that I can do?
View 19 Replies
I am working with a friend on his 2004 v8 toureg. It dies at idle after a few moments. I thought it was the usual coil issue cause he said the thing was misfiring like a mother so i replaced the coils and got rid of the misfire but still died. Then i noticed that one of the plastic linkages was broken on the air velocity flaps on the intake manifold. Tried holding the flap open but it still dies. Is it possible that the ecu is shutting the car off because of the air code from the flap?
View 4 Replies
My 2004 Focus passed its emissions test in Maryland in the late fall last year. Shortly thereafter, the check engine light came on. My mechanic put it on the computer and said it needed a new catalytic converter. It only had 86,000 miles on it. I watched and waited for a few months and had the fuel filter changed during a routine oil change. A couple of days after the fuel filter was replaced the check engine light went off and stayed off for 4 months, but it came back on a couple of days ago. I have been watching the mileage carefully and it has been steady at about 26 MPG for years.
View 5 Replies
Is it fair to assume that my filter is clogged when I turn over the engine and fuel does NOT come out of the filter with the uphill line disconnected. I was able to disconnect the rear line from filter and fuel DID pump out of line when I cranked it over. Been dealing with a crank no start, I'm in the process of trying to test my CPS properly but not sure if I'm testing it right.
2000 f 150 4.2 v6 232,000 miles....
View 7 Replies
Just had a new issue pop up - sometimes, when making a sharp left turn when the engine RPM is low (going into driveway, turning at a stop sign), the engine will suddenly die. It seems to be running fine otherwise, it does not idle rough, and the idle RPM is around 600-700. It never dies on the highway or higher speeds, yet anyway.
I do notice that my power steering pump is making a little noise. It is an aftermarket pump. The steering assist seems to work fine though.
I recently had the spark plugs, valve cover gasket, and a fuel pressure sensor replaced. As I understand it, the mechanics checked the fuel pump and it was working fine.
View 3 Replies
My mom gave me a 2004 f150 lariat with a 5.4l and were having an issue with the engine when coming to a stop the engine wants to stall out and runs like a bag of hammers and sounds like its going to explode then i give it a shot of fuel and it runs fine for a a while and then does it again. I brought it to the local dealer and he said it was either the vct or the cam phaser bank 2 so i changed both and it still does it just wondering before I keep getting intake cam sensor code retarded and a bunch of other codes but we replaced the cam sensor already.
View 2 Replies
I have a '00 RAV4 I bought from my Mother. It was having loss of engine power and it would stall while driving and then turn off while driving. The car was taken to 4 mechanics, non could figure it out changed the sensor air fuel ....worked then did it again sent to the Toyota dealer changed the same part ....the problem seemed to be fixed....I've had for a couple of weeks and the problem came back...what I notice was a low idle, loss of power....then the car started stalling while driving, the rpm idle dropped to 0 and car shut down took to mechanic said the throttle body was dirty . They cleaned it they said that it fixed the problem ....2 weeks later it happens again to 2x .....I don't know what to do ...
View 1 Replies
I was driving when the truck made a terrible noise and while pulling over the check engine light went on as well as low oil pressure. I turned off truck and checked but no evidence of any leakage at all. Checked oil stick and was dry. Let sit for an hour and checked oil stick to find about 1/2" showing. Added oil to find that now it was overfull, drained oil back and stick showed proper level. Attempted to drive and it was fine until I came to a stop wherein it would stall with "low oil pressure" showing and check engine light on. Brought to shop and they said engine is very gunked up, they said they could try oil flush but probably will not work. They most likely will have to remove the valve cover and such to physically look at engine and take it from there... (I have always used type of oil stated on the cap, used synthetic and changed every 5-7k miles - showed diagnostic codes p0011, p0340, p0345 and p0021).
View 14 Replies
I recently bought a 2006 STX with the 4.6 engine. Occassionally, when stopping at a light, the engine will stall. I took it to the dealer where I bought it and he put it on the computer and found that once on a test drive the RPM's dropped to 490, but it did not stall. He said everything checked out fine and thought it might be a carbon build up, since the truck only has 27,000 miles on it and was driven only around town. He suggested a couple of tanks of higher octane fuel and a fuel additive to remove the carbon.
View 10 Replies
My 04 F150 has started having a rough idle. While in park the engine will stall out with the A/C off. Also when in drive the truck will idle close to 1000rpm's. I had to the fuel filter cleaned and also the MAF sensor cleaned. Also did a vacuum check on it. Pulled the code and it's throwing a Lean Code. What else should I be looking for?
View 12 Replies
5.4 L, Engine runs if primed at the intake. Fuel pump can be heard running but no fuel gets to the engine. Truck is mint and being sold real cheap due to this issue.
Fuel Pump? Filter? Both? I haven't seen the truck, a friend is considering buying it and rolling the dice it is a quick fix. Fuel is in the tank .....
View 2 Replies
My 2005 Ford Focus just came out of the shop getting the alternator replaced. Driving down the road it just died. The car still has power, Lights, interior lights, all that stuff is on. I turn the key and nothing.
View 6 Replies
My car was driving good when i had an accident just the fender and door was hit, but i loved the car in the body shop for 1 1/2 years now i went to pick it up and the battery is low, the gas engine start and stall in 3 or 4 seconds . Can i tow the car with the wheels on the ground and been pressing the brakes a little to re charge the battery, 2007 prius 120000 miles.
View 7 Replies
