Elantra XD (2001-06) :: Power Steering Leak / Fluid Below Passenger Side Of Rack
Oct 28, 2012
My power steering seems to have sprung a leak. There is quite a bit of fluid below the passenger side of the steering rack. The leak seems to be right below where the power steering hose comes down off the pump, gets secured to the chassis and changes to metal line from rubber. The metal line then goes into an L bend and is routed towards the driver side right where the leak apparently is.
I haven't had a chance to have a good look, as it was 10:30 at night when I parked it and looked (12km of careful city driving since it started to act up)
Is this a high pressure or return line?
The leak seems to be forward of the steering rack, so hopefully I wont have to replace it.
View 8 Replies
Advertisement
Replace the seals in a power steering rack on a Passat? I recently noticed I had a fluid leak after seeing spots on my driveway. After discovering it was power steering fluid when I checked the reservoir, I checked all the lines and found the leak coming from the rack on the drivers side. The boot on the steering rack had come loose and there was fluid leaking from the side of the rack. Is there a fix for this or am I looking at a expensive repair?
View 6 Replies
I have recently replaced the clutch, clutch master cylinder, clutch slave cylinder, Strut tower mounts and brakes on my 2002 Hyundai Elantra 5 speed. Everything is working properly but now I have a transmission fluid leak. I can not locate the exact location. It appears that it is dripping down onto the passenger side half axle where it connects at the transmission.
View 2 Replies
I own a 03' 2.7 Santa Fe (2wd) and when I got home last night i noticed that she was smoking like crazy (not overheating). Opened the hood looked under the car and noticed some fluid spraying on the the exhaust and leaking down from there which was causing the smoke. I put her on jack stands and noticed what looks like to be some hard (i think pressurized) lines that are attached to a connector of some sort in front of the steering rack. What lines are these? Power steering? oil cooler? Transmission related? The fluid that is leaking looks like transmission fluid cause its reddish brown. Ive worked on a few other cars before but not too familiar with Hyundai. When i get home later I will take a pic of this area and post a picture. And it looks like its spraying from the connecting lines (maybe a crush washer gone bad? ) not sure. I can't seem to find any image of this area online either.
View 2 Replies
I have a leak coming from the top of my reservoir from the under the cap for some reason. I bought a new cap and it seem to stop for a day and now it leaking out from under the cap again. What is the reason it would be coming out of there. Am I going to have to replace the reservoir??
View 1 Replies
2004 XG350 with the Sigma engine, 133,xxx miles.
In the picture I attached, the large silver bolt is leaking. Its a slow leak: yesterday morning I wiped it off, and then we I got home from work there was a bead of power steering fluid, but not enough to drip.
What is the best way to fix this? Is it as simple as tightening it?
View 3 Replies
A few days ago, my car developed a loud squeeling noise coming from the belts. I opened the hood to find both caked on and still wet PS fluid all over the left side of the engine compartment and the belts/pulleys. Most of the mess was concentrated near the PS fluid reservoir and the two hoses attached to it (picture of hoses and reservoir below from Google). This leads me to believe there is a leak in one, or both of these suction hoses. I will replace the hoses but my question is how should I clean up the fluid on the belts and pulleys? Should I use a soft brush and a rag with soapy warm water, brake cleaner and/or engine degreaser to get all the gunk off? I would really loathe having to have to put in new belts, seeing as that I just had all the belts changed 6 months ago. This squeeling noise makes my car sound like some old junky clunker and I hate it.
View 2 Replies
2005 Santa Fe (88K, 2.7 V6).
For a month or two, after the car got warmed up, I'd hear a whine/hum noise when I slowed to turn or reduced speed. The noise was much more noticeable when the car had been running at least 15-20 minutes, but I did occasionally hear it when the car was somewhat cool still. Never had a problem steering during this time, even with the noise... but I eventually figured out that slowing down and/or turning brought it on. So I took it to a mechanic.
They showed me bubbles coming from the power steering reservoir, and said I needed a new PS pump and pressure hose, along with a flush/new fluid. I paid for all of that.
Next day: The car would become hard to turn when I made a tight turn into a parking spot... again, not a constant thing, but only when turning to park and going slow. The noise APPEARED to be gone, but this new issue worried me so I took it back. They put a different pump on (no charge), thinking the other may have been defective.
Next Day: I hear the whine again on my way home from work. When I get home, I park, leave it running, and pop the hood. There's a fast drip bubbling from beneath the reservoir cap and running down to the pavement. First thing the next morning I return to mechanic. He says the first two pumps were the same brand and both "remanufactured" so he switches to a different brand -- this one brand new, not "remanufactured" -- and installs that one.
A half hour later, I get home. Hearing that same whine/hum, I lift the hood. Fluid is pouring out from beneath the cap in a steady, unbroken stream (not a drip, but a stream). So I took it back to the mechanic (who to his credit, has charged me nothing since the initial new pump installation). What could cause the power steering fluid to gush out from the reservoir cap when the car gets hot? I have a brand new pump and pressure hose. What could cause this condition..
View 12 Replies
I have a 2000 taurus and I have been having trouble with my power steering. Its leaking badly & from where I see it is Leaking is under the car on the passenger side by the tire. Also essentially the taurus power steering runs on transmission fluid so could it be a practical idea to use trans stop & sea to slow the leakage til I get to a mechanic?
View 4 Replies
I need to replace the power steering rack on my car. Mech wants 300+parts. I supply the parts. Is there a different rack for the vr6 VS the I4 jetta?
View 1 Replies
My 2002 Elantra (about 276,000km) had some kind of leak in a power steering return line. A mechanic looked at it, said I needed to order the replacement part from Hyundai. Got the part, the mechanic (not Hyundai) took 2 hours and fixed the line.
Driving away from the mechanic, I noticed the front right turn signal was blinking abnormally rapidly. Left turn signal is fine. I call the mechanic, tell him what's happening, and ask if it might be related to the power steering line fix (after all, they're both in the right front side of the vehicle). He swears up and down he touched nothing having to do with the turn signal.
Okay, maybe it's just a coincidence. I buy a new signal light and put it in. Same thing with the front right turn signal blinking too rapidly. While driving back from replacing the bulb, a car cut in front of me and I went to lay on the horn....nothing happened!! No sound. To top it off, for a while now, the dashboard lighting has been dimming slightly at certain times.
What could be causing all this? The alternator is fine, someone tested it.
View 4 Replies
So I went outside yesterday, an hour after getting home from an hour drive. I find a PUDDLE of transmission fluid under my car. The only place WET under the car, however, is under the passenger side (where the antifreeze is). When the flat bed tow truck arrived and lifted the car onto the truck, there was a line of fluid that leaked out where the car was pulled onto the bed at an angle. When I spoke to the mechanic this morning he said he can't find a leak anywhere. My transmission fluid is full as is my antifreeze. So where did the leak come from and why isn't it happening now?
View 2 Replies
I own a 2002 Elantra GT that's had a decent repair record but just yesterday developed a leak that is almost exactly 18" toward center from the outside of the right front tire and 5" to the rear of the center of the tire (18" in, 5" back from rf tire). It doesn't seem to be a small leak and unfortunately I don't know what the fluid is. I've never changed the oil myself and have never seen the undercarriage. The measurements were made by marking the the concrete by the front tire then measuring in to the deposit.
View 2 Replies
2009 Sonata 2.4L ... About 60 000km ago, the complete steering rack was replaced under warranty. Now I notice the PS fluid going down in the PS reservoir. I checked for any loose fittings, all look OK. But I did notice PS droplets hanging from the steering rack boots. So today I replaced the PSF4 fluid with Amsoil PS fluid. I suspect maybe some seals are leaking. Any good product I can use to maybe stop the leaks?
View 1 Replies
I have a 2006 sonata 3.3 with auto trans I'm having trouble with fluid leaking from the passenger side axle seal. I have already replaced the seal with a Hyundai seal and it is still leaking. Not as bad as before but it leaks onto the exhaust and smells really bad. The transmission is not overfull...
View 2 Replies
2003 Limited 6.0 130K. Just took a 1000 mile trip for spring break. While away, I noticed a small leak near the front passenger side of the truck. It is red so I assumed it was transmission fluid. It is leaking from, the best I can describe, a small housing that looks like it might be a filter near the tire (it looks like the old style canister oil filter housings). All the hoses are clean and where the hoses go into the radiator are clean. Is this an easy fix? I am a bit worried about trying to get the thing off without damaging the hoses.
View 3 Replies
The steering fluid pump reservoir has a leak ive been told by my trusted mechanic. The first bout of cold below freezing weather, the steering fluid drains out and I have to refill it. After refilling, I'll have to fill it again in a few days sometimes lasts a few weeks. Might not have the car for much longer. How to cope with this rather than get a (expensive I was told) new steering pump.
View 2 Replies
I recently noticed that my brake fluid was leaking in my 2003 Hyundai Elantra and upon further inspection I found the leak was coming from a part near the master cylinder. I looked online and couldn't figure out if this part was part of the master cylinder or brake line or a part all on its own. I tried tightening it but It still leaks some. I read a similar post online and that it could just be that the washer needs replaced but I just wanted to check on here to see what the part is called and if I should just replace the whole thing. I included photos as well.
View 7 Replies
I know I have a leak in my power steering fluid return. I bought the big expensive green jug and top it off when I need to. The past few days, when I start up my car and turn around in the driveway, there's a groan when I turn the wheel in either direction.
View 3 Replies
Here are my questions.
1. What can cause repeated steering rack failures, which I am trying to dianose?
2. I found yellow spots in the snow that would come from the center of the vehicle (as opposed to near the wheels), could this be from the coolant system?
If you got that far, here is the relevant history. My wife drives my 2000 Jetta, its a nice car with repeated problems. One such problem is with the steering rack. 1. The steering rack failed in 2006, it was an expensive fix. It was leaking for a while, but I just topped off the fluid every couple of weeks. 2. Within a year the steering rack failed again, it was still under warranty. 3. 2 years later, the rack failed for a third time. I wrangled with the shop and they agreed to reduce my price for the fix even though the part was no longer under warranty. They had the car for a week trying to diagnose the problem, they said they found nothing out of the ordinary. I took the car to another mechanic a week later for some other issue, and he saw leaking from the fill plug--back to the dealer again. They said they cleaned the washers around the plug to fix the problem. No problems since then. Now its almost two years later and I have found a couple yellow spots in the snow, although near the center of the car and not near the wheels. This makes me think it may actually be a coolant leak, but I don't know right now.
View 1 Replies
My Camry 2011 (55k miles) had complaints of power steering fluid leak and needs rack and pinion assembly replacement.
I have powertran warranty only, so this one is not covered and when asked for the dealership for estimate, they said it would cost around 1700$.
Can i get this replacement done at local shop, if so will there be any problem to my powertran warranty ?
View 5 Replies
