Elantra XD (2001-06) :: Cannot Fill Fuel Tank / Gas Overflows When Filling
Mar 11, 2014
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.
View 10 Replies
Advertisement
After over filling my fuel my car stalls (sometimes) on going back to idle. Not sure what to checks, check engine light is not on.
View 2 Replies
I have a 2008 Hyundai Sonata that overflows at most gas stations when filling. To fill the tank, I set the pump on autofill and walk away. The pump clicks off and then the car "burps" and gas comes out the filler neck and runs down the outside of the car and out the bottom. It does not do this at one gas station by my house but seems to at all others almost every time. The car is still under warranty (42,000 miles but the issue started at 29,000) and I have brought it to the dealer 3 times. Each time they claim to have found something new wrong and fix. The first time they replaced the fuel filler neck, 2nd time fuel filler neck assembly (and tested at a gas station and it worked), 3rd time the vent valve. Each time I try it and it overflows for me (except at that one gas station). I have never had this issue before with any other car including my wife's current car. I'm truly stumped, but feel that a car should be able to fill up at a gas pump without overflowing.
View 3 Replies
My 2003 Expedition has started spraying fuel out of the fill tube whenever I fill the tank. It started 6-8 months ago. At first, I thought that maybe it was a fluke. It kept happening. I am so tired of getting fuel all over myself and my car. Not to mention the environmental impact of the fuel spill. This isn't just a little fuel dripping out of the tank and spilling on the ground. It's a full on projectile expulsion of fuel from the tank. What's happening and what I can do to fix the problem?
View 4 Replies
First time I've filled the car up and getting a gas smell while driving. I checked the gas cap and it's on.
View 3 Replies
At seemingly random times when I take my Elantra to the gas station it will only fill the tank about half way before clicking off. After doing some quick google searches I'm leaning towards something being wrong with CCV system. I read that over filling the tank can cause debris to clog the system and a few months back my father-in-law borrowed it he has a tendency to overfill the gas tank. But I've also read that there's an error code that tends to pop up with it and so far there's been none. Either way I'm not familiar with how the CCV and related systems work.
View 3 Replies
Son was unable to fill his car's gas tank, 2002 Elantra (but happens to all cars sometimes).
The vapor lock on the pump kept shutting the gas flow off.
This was caused by the tanks vapor exhaust being unable to exit while filling, so the only place to go was back up through the gas fill hole.
The charcoal filter had sprung a leak so the zillions of tiny little charcoal pellets pour from the filter into the rubber hose clogging it.
The Filter is $150 at Hyundai. Not available at AutoZone or OReilys.
Very simple to replace a couple bolts a few hose clamps.
Strange problem, thats no one at work had encoutnered before. A few Hyundai mechanics had heard of it and worked it before.
Also could be Purge Valve or Vent Valve solenoids...search EAP system too if your having this issue of not being able to fill your tank with gas, without 500000 vapor locks shutting the pump off!
View 5 Replies
I just changed my fuel tank and now when I try to fill it up it keeps blowing back it never did this before.
View 2 Replies
Like a lot of others, my 2000 Elantra will just barely take gas at the pump. So I've done the research, I think I understand the problem, but when I tried to find the replacement filter, there seem to be 4 different parts ranging from $8 to $180. Which part should I order and order first, or should I just replace them all?
View 4 Replies
My CEL came on today, gas level was a little under a quarter tank.
Took it to Advanced on the way home to have them scan it quick, and it threw a fuel pressure regulator code. I stopped in the gas station on the way home and filled it up, and the CEL was gone and hasn't been on since. I'm thinking HPFP, but maybe not? Could it be injectors?
View 4 Replies
I filled my 2010 Prius IV. Every day since, my indicated MPG has gone up about one MPG, with my 40 mile round trip to work.
I had been running around 46-48 MPG indicated this winter. Next day it was up over 50. Yesterday 52, today it is up to 53 mpg and I have used 1/2 tank on 256 miles, which is much better than my winter stats.
View 6 Replies
How many miles does it say you can drive after you fill up? Mine says 334 and that's what I'm getting. I want to hit 400 for a tank and can't.
View 13 Replies
Normally when I fill my fuel tank, of course the car is off/not running. And once it is full and I get I'm the car then start it, the "Cruising Range" read out has always read about 403 mi.
Right after the recall was done, it read about 420 mi. if I recall correctly, but in the next fill up or two, it's remained at 403/404 mi.
However, today when I filled up and got in the car, the cruising range read 387 mi.
The tank was between 1/4 and 1/2 full before fill up.
View 14 Replies
I'm not topping off or overfilling, I pull the nozzle out once the I get the 1st click/cut off whatever from gas pump nozzle once the tank is full and don't put in any extra. It doesn't do this right away (Power loss)... waits until I shut the car off for the day (after a fuel refill) and then the next day I'm driving along and for 20-30 minutes I get random complete loss of power. I don't think it's an ignition issue because it only happens when I fill the tank, but it sure feels like it. It's almost like that bad coil pack feeling. I don't know how else to explain it, just stops accelerating/cruising for a half of a second maybe once every minute or two for about 30 minutes, then it never happens again until i fill the tank.
View 9 Replies
I have a 2012 Prius 3 that's about 1 1/2 months old with about 1,500 miles. I remember when it had 3 miles and the dealer filled it up it showed a 600+ mile range. Since then I've had a few fill ups where I've gotten it down to about 20-40 miles left in the range and when I fill it up it's only filling up with just under 10 gallons and showing a range of about 475 miles. If I remember correctly the fuel tank is 12.9 gallons so I feel like I'm not filling up to those last two gallons. Not sure what's going on.
View 2 Replies
Well, just got back from my dealer - had them check into why after driving approximately 20 miles my fuel gauge registers 3/4 full. They said it has nothing to do with the cluster gauge everything checks out as accurate. My vehicle had the ECU 293 update applied at production. According to them is it because there is something preventing my fuel tank from filling all the way up. According to the service rep when the pump clicks off, my fill up is about 3-5 gallons short.
When I took delivery of the vehicle I noticed that the distance for the remaining (full) tank of gas read around 384. I've never seen that number again. Now when I do a fill up the best tops out at 310 or so. Where exactly did my 70+ additional miles until empty go?
They opened a case for my vehicle with Hyundai and said that Hyundai is already aware of this problem and they are working on a repair.
View 12 Replies
Having trouble filling gas tank, the pump nozzle keeps cutting off. Have to fill by dribbling the fuel in until filled. What the problem might be?
View 5 Replies
2007 Pacifica with 4.0 will not fill unless you dribble the fuel into the tank. I have cleared the vent hose and know it is clean. Do I need to change the Carbon Filter and Solenoid/Evaporation Valve on the Front of the Carbon Filter?
View 7 Replies
I just bought a 2014 Prius- Pkg. 2 car. I had an '06 & an '08 Prius and kept the tire pressure @ 44 Lb.s for maximum mileage. I always fill my tank to the top well after the pump clicks off.
1) The dlr. told me I will only get an accurate MPG by not filling the tank after the pump clicks off. He claims the computer doesn't read the extra 1-2 gallons and that is causing me to get about 35 MPG even though the trip meter says 50 MPG.
2) The dlr. told me not to run my tires @ 44 lbs. Said it is a safety issue. I've been doing 44 lbs. since 2006 with great mileage and no safety issues.
Am I wrong for filling my tank to the top? My Prius has just over 600 miles today.
View 19 Replies
I have a 2007 Santa Fe. If I fill the tank to full, or close to full I will have a fuel smell in the car until the tank runs under 3/4. If I keep it under 3/4 I usally do not get the smell in the car.
The dealer could not figure it out and I still have this issue. It seems the smell is more in the front of the cabin then the rear. It just could seem that way since the smell is very strong. I have to park the car with the windows open.
There are no fuel leaks, no fuel on the ground, no drips, and the no spillage when I filled the tank.
View 6 Replies
Ok so the fuel gauge says empty and the low fuel light stays on even though the tank is full. I'm assuming its either the gauges or the sending unit. If it is the sending unit where is it located on this car?
View 4 Replies
