Elantra XD (2001-06) :: 2002 GT Not Starting After Water Pump Replacement
Nov 29, 2013
Just finished installing a new water pump on my 2002 Elantra GT when...
I went to start it, and it started for half a second and died. Further attempts to start were strained.
The battery is showing 12.58 volts on the multimeter so this was likely not the cause. I checked the fuses under the hood which all looked good. I don't know if it could be a relay or anything else electrical.
Other than the electrical side, there are two things I can think of that may be the cause.
First, being in a hurry to finish(which is probably the biggest mistake of all) I reconnected the battery too soon and wound up connecting the ground(I thought) wire to the alternator for a second causing an arc. I immediately removed the wire and followed proper procedures to reinstall it.
The only other thing I can think of is that one of the water pump bolts required removal of the idler pulley. The idler pulley demands the loosening of the timing belt tensioner in order to be reinstalled. Before removing anything I marked the position of the timing belt on the camshaft sprocket as well as the crankshaft sprocket so I'm really hoping I haven't lost timing.
Could it be something electrical? Did I over-tighten a belt or pulley? Is it timing?
View 15 Replies
Advertisement
So the water pump on my early 99 (158k miles) is starting to leak just sitting in the driveway, did a little research last night and read a few write ups. Just wondering if any tips or tricks I could use to make this go easier. Also any list of parts I should replace and/or might need. I read on one write up about replacing it with an Airtex water pump and was wondering about what people thought of those, I would rather fix it right then just go with the cheapest parts. Possibly there are better brand water pumps out there?
View 5 Replies
I have a 2002 Audi A4 1.8T with 85,000 miles. Recently my car started overheating, I replaced the water pump, thermostat, and timing belt. The mechanic also ran tests to make sure there were no issues with the head gasket, those tests came back saying the head gasket was a-ok. Yet, my car is still overheating but only on days when the outside temperature creeps above 90 and I am in stop and go traffic. I have to re-fill the coolant tank about once a week depending on how much I drive. I find no coolant puddles under my car when it is parked, so I do not believe it is leaking. What else could be causing my car to overheat?
View 2 Replies
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
View 12 Replies
After tracking a howling sound from my 02 elantra gt pulley are, I figured it to be the water pump bearing. I replaced the water pump less then a year and a half ago and was wondering if its common for aftermarket pumps to go fast? Or is there anything I did wrong installing?
View 1 Replies
I have an 2002 which I bought new. It's got low millage, just over 92,000. I took it into the dealer for a free state inspection and was told that the water pump is leaking. Given the age I'm not too surprised although I don't know what the reliability is like on that part.
I want to verify myself that the water pump is actually leaking before having it replaced but don't know where it is or what to look for. Googling hasn't been too useful - I get lots of hits about the inverter pump, not the water pump.
I have not seen any signs of leaking on the ground under the car. There was no mention of the water pump leaking when I took it to the dealer at 90,000 for an oil change, with my original service advisor.
Is the water pump something that I can fairly easily inspect? Where do I find it and what do I look for?
View 6 Replies
My daughter has a 2004 Toyota Corolla and the "service engine" light came on. The diagnosis was that the water pump needed to be replaced.
View 1 Replies
How do you replace the reverse light switch on a 2002 Hyundai Elantra manual transmition?
View 3 Replies
So for about two months now, every time I get gas, the pump cuts off almost immediately after i start pumping. After that, I am able to pump about a second or two before the pump shuts off. It recently has started spitting gas back out of the tank (I'm assuming it's the gas I just pumped into it being spit out). I'm not sure what is wrong. I have not gotten into an accident, there is no smell of gas in the car, the gauge still works fine, and no check engine light on.
View 3 Replies
08 Prius now at 120k. This is usually when I change the ICE water pump. I've been reading about when to change the pump, and it looks like opinions are all over the place. Generally though, consensus seems to be "change it when you see pink crystals on the pully." Is this correct?
120k is usually when I expect to drop a couple of thousand on preventative maintenance. Is this not true on the Prius? I knew running costs were low, but THIS LOW?
View 8 Replies
I am trying to replace a water pump on a 2006 Hyundai Sonata, 3.3L, V6. But I hit a snag. I have removed the drivebelt but I can't get the water pump pulley off due to clearance. The water pump pulley is hitting the engine mounting bracket. All the manuals said I could remove the water pump pulley and the water pump and made no mention of removing the engine mounting brackets. I was wondering if there was a way to remove the water pump pulley, and the water pump, without dropping the engine and removing the engine mounts? If I do have to remove the engine mounts, do I need to remove the mounting brackets on both sides?
View 13 Replies
92 PA Base ... Attempting to replace water pump. Is a hydraulic jack required to hold up the engine when removing the engine mount? The engine mount (passenger side front) is covering the right portion of the water pump. Although the engine mount has two holes for the remainder bolts of the water pump, there's no room to fit a ratchet or anything to remove the remaining two bolts. It appears the mount must be removed to replace the water pump. Is this so? How to correctly remove the engine mount.
View 1 Replies
My ICE failed to start on a wooded forest road -- after the car had sat under a fir tree for a day or three it ended up starting and all the warning lights went away. I ended up taking it to the dealer though and while they replaced a leaking water pump, never found any cause for the ICE failure.
View 2 Replies
My car just hit 70k miles, I have had no problems with my car since 28,700 miles. I kinda drive it like an old man I know I know I should be ashamed of myself lol. When do you find most 04 .:R's Waterpump/timing chains needing replacement? Just curious if I need to factor this into my budget.
View 7 Replies
1995 Isuzu Rodeo. Replaced water pump, thermostat, timing belt & components. Now it over heats & no heat in cab. I was told to "burp" the cooling system but can't find the bleed valve. Is there even one on the V6 engine???
View 3 Replies
09 Toyota Corolla 75,000 miles. The garage where I have my car serviced 2X a year (oil change, minor tune-up at 7K miles) says the water pump is starting to leak. I haven't noticed anything, but the mechanics suggest a $600 repair. First, is this a common problem with my model car? Second, is the estimated fee appropriate? Is the car or am I in any immediate danger (how long can I put this off)? I've only been going to this garage for a couple years as my previous CarTalk-referred mechanic retired. I'm not sure whether to trust the new guys (no longer a single individual, but a group of mechanics in a middle class residential suburban neighborhood).
View 14 Replies
1999 Olds Alero with 2.4 L engine...
Everyday when I back out of my parking spot, there is a large puddle of antifreeze under the car, mid point near the firewall. I have to add 1 liter of antifreeze a week/100 kms. I am thinking it is a "low pressure" leak, cause when it is running, there is no major spray noticeable. Weird. So I have done some reading and can only guess that it is my water pump that is shot.
After getting the estimate from the local garage of $ 700.00 (mostly labour) for a $ 100.00 water pump, I am going to tackle this one myself. Can't believe Oldsmobile did just a crazy thing like hiding the water pump so deep into the caverns on a 2.4L.
I am not overly concerned with this bigger puzzle, but want to be sure before I get it all apart and tie up the prime spot in the garage called the "wife's parking spot". Got to get it in and out quick. Will I need any specialty tools, for things like removing the timing gears or anything else that is goofy on this repair job.
View 1 Replies
Had the Check Hybrid System and master warning light come on today. Took it to the dealer, who, after a couple hours, told me that my "Hybrid Water Pump" needed to be replaced.
View 19 Replies
How to change the timing belt and water pump on a 2006 2.0t passat?
View 3 Replies
Have air trap in coolant after water pump replace.cannot get it out. Do I need to drain coolant again and start over. 1997 nissan pickup 2.4 liter.
View 3 Replies
I have worked on several minor to moderate engine issues over the years with various brand cars so I was thinking about replacing my leaking main water pump (not the Hybrid pump).
View 9 Replies
