Dodge - Grandcaravan :: 2002 - Blows Black Smoke - 16 Mpg?
Jun 14, 2011
I have a 2002 Dodge Grand Caravan and I am having an issue with it running a touch rich and not getting the gas mileage it should. Here we go, in March the van started to start hard and blow black smoke out of the exhaust. After a 120 mile drive back home, one morning it would not start. I pulled to a mechanic who went out and started it without a problem, he said it was flooded out and probably needed to change plugs and wires. I took it home and changed the wires and plugs. Much to my surprise, no change. The van started hard and then ran really rough with no power for a while and was polluting the air with black smoke. The average mileage was around 12 mpg. I went to the next step and changed the coil pack. No change. Finally took it in and the mechanic changed the O2 sensor and the cat converter. The can runs better but still gets around 16 mpg and still blows a small amount of black smoke. Oh yeah, the air filter is clear and there are no trouble codes either. I am thinking it could be a something with the fuel delivery system maybe?
View 1 Replies
Advertisement
There's a black form around the end of my minivan tail pipe. This form is created by smoke, I can have it on my finger if I touch it (like BBQ ashes), is this normal or my minivan running rich? I don't see any black smoke coming out of the tail pipe as it is driving.
View 4 Replies
So i just spent over $1700 at a vw service ctr having a sched 140k timing belt replaced with thermo and fuel filter. This was 3 days ago and when i picked it up it was slower to turn over then got worse and todsy it won't turn over at all even when jumped. It cranks and blows black smoke. Problem is i'm 160 miles from that svc center and it's sunday. There is a vw svc center 14 miles away but i feel like it needs to ho back to where the work was done because it ran great before taking it there.
View 5 Replies
I have looked through every post and idea possible with no remedy for my no start condition. I have tried everything that I am capable of doing without diagnostic computers and other specialized tools. A little history of what happened. While idling in the parking lot for a few minutes, truck all of the sudden start running rough, and acts like it is going to quit. Hurried out of the parking lot to make sure that I made it home, but the the truck would only get up to about 25 MPH, but I finally made it home(about 3-4 miles).
NOW, the truck won't start at all, but just cranks. Some more detail about how it cranks. It cranks fast, I separated the batteries by disconnecting the grounds on each, and made sure both are charged. Batteries are only 3 months old from Ford Dealership. As the engine cranks, oil pressure registers after a little while, (longer the first time for some reason), and as soon as oil pressure shows up on the dash indicator, black smoke starts coming out of the exhaust. The engine is trying to start a little bit, but it mostly just cranks.
Things that I've done: Changed fuel filters, Motorcraft (new orings). At first the pump was pumping large bubbles through the line up into the upper fuel filter, but after sitting it appears that it is not pumping bubbles anymore, and I cycled the Key more than 10 times. Did the bubble test while upper filter was removed. Unplugged ICP sensor. Pulled EGR, installed new one. Pulled oil filter and made sure that oil is pumping.
Checked FICM voltage, with key on Injectors buzzing, also engine cranking for quite a while. Never dropped below 48.5 V. Pulled FICM just incase and performed repair procedure, still same volts and no start. Coolant level is good. Checked oil level. unplugged EGR. Checked filter Minder. checked for chafing on FICM harness. Unplugged MAF. Checked FICM relay operation, Fuses all around. I need this truck to run.
View 9 Replies
I just had my van inspected and tires rotated...van sits for a few days then travels 20 miles and am now smelling something burning and smoke is coming out from front right tire. Other discussions say calipers/pads and that's ok BUT my question is since my van only has @24,000 on it, did the mechanic do something when he rotated my tires? I am a senior citizen and only use my van once a week.
View 6 Replies
Working on a 1998 intrepid got the codes po134 po171 po154 and got all the codes taking care of except 1 po134 which it says its a oxy sensor just took it for a test drive after about 10miles it starts spewing black smoke and trying to stall out, then it clears right up after that.
View 2 Replies
I have an 02 DGC with 187K miles. 3.8L There has never been any work done on engine or trans. We do regular oil changes and I just had a complete scheduled maintenance overhaul done about a year ago, including the trans. And as a matter of full disclosure, my wife and I are prob not considered "easy" drivers.
A few weeks ago, when I put the van in D, it won't engage. No problem with R, just D. After a few minutes it engages and off I go. If I warm the car up first, this does not happen either. And it won't happen the rest of the day. The only other "funny" thing it is doing is, when I slow down, there is a definite movement or catch as it shifts down around 20-30mph. It feels as though the gears are having trouble downshifting.
I took it to a mechanic and he said the life span on this trans is about 180K and so I need a new one. Does that sound correct?
View 16 Replies
My 2002 Dodge Grand Caravan transmission suddenly does not changing in gear This happened when I was driving. The engine light came one and transmission seems to stuck in a gear. Acceleration is fine but the van slows down quickly if I let go the gas pedal. Seems like it stuck in a gear. How to I troubleshoot and is there anything I can do at home?
View 19 Replies
I have an odd issue. I bought my car used from the dealer. The fuel pump was replaced last December, as well as had an oil change. The fuel pump died right after the oil change but are seemingly unrelated since the pump was bad when i bought it. After the pump was replaced my van stated acting up over the next couple days. The fuel gauge would dance randomly. That has since settled down. Now when i make left turns, the rpms drop and i have to pump the had to get it going again or else it completely stalls out in the middle of an intersection. .. it had been steadily getting more frequent and only on left turns. Right turns runs fine.
View 3 Replies
I have a 2002 Grand Caravan, when foot is on brake, speedometer jumps all over, engine bucks so bad I have to put it in neutral or park at every red light. When I go forward, it jumps a little, and sometimes will not shift, engine revs up so bad, I have to pull over, shut engine off, turn it on and then it shifts. Speed sensors were supposedly replaced with the plug for them. It is at a dealership, they checked all the sensors, electrical wires, etc, and not it doesn't shift at all!! It is still there, now I have no van to drive. They claim they did nothing to it, it was shifting 90% of the time. It will not shift at all, even when I shut it off and re-start it. Now they claim it may need a new used tranny.
View 1 Replies
My 2002 Dodge Grand Caravan has a sound metallic rattling at about transaxle area (I am not sure if it's a transaxle issue) when it's cold but when it's at operating temperature, I don't hear it anymore. Fluid level is correct and clean, I just have the fluid changed. Shifting is fine, just annoying sound, not loud but it can be heard easily.
View 4 Replies
2002 dodge grand caravan. We feel the heat from engine block inside the two front seats (driver and front passenger). We also feel heated wind (blowing strong) and smell coolant when standing outside the vehicle by the driver and front passenger door with the engine idling.
There's visual small leak, once the vehicle is parked. I wonder where the leak is (not on radiator and the radiator coolant level remains full). I bought Preston Radiator Complete Care and Stop Leaks. I haven't put it in yet, just wonder if this will work.
View 9 Replies
My 2002 Dodge Grand Caravan's most recent problem has baffled 2 garages so far. It is now in a 3rd one that specializes in auto electric issues. When I turn on the left signal it flashes a few times then the RIGHT side starts to flash. When I turn the right signal on you got it the LEFT side flashes! I installed a new multi function switch and NO CHANGE!
View 6 Replies
Upon cranking my 2002 Dodge Grand Caravan and driving app. 10 miles the speedometer and odometer will stop working and the motor will sound strained for the rest of the driving time. The rpm's go up and it dies from time to time when making a quick stop or turn. It starts right back up. The next day upon starting again the process starts all over. What's the problem?
View 1 Replies
I have an '02 Durango, and the AC only blows cool air when going down the road at 25+ mph. I thought I'd try putting some refrigerant in, but when I hooked up the gauge on the can it buried the needle, so it's over 100 psi on the low side, and the pressure was high enough that no refrigerant would flow in. Up where the lines attach to the expansion valve, when idling the in line is HOT - like too hot to keep your hand on and the out line is about air temp. The guy at the parts store thought the expansion valve was bad. As stated, AC works okay (but not excellently) while going down the road.
View 6 Replies
I have a 2002 Dodge Durango and the rear passenger air blows cold only - was fine last winter. Neither the passenger or the driver controls will get warm air to the rear via the overhead vents. Warm air comes out under the front seats to the rear only.
View 1 Replies
I've been told by friends driving behind me that every time I accelerate I emit a plume of black smoke followed by a stream of black colored "water". I checked today by having the wife rev the engine to 4.5k...sure enough, black water shoots out of my exhaust, probably 3 oz. I also see a black puff of smoke which I assume is more normal than the water. Is this commonplace ?
View 2 Replies
2002 Ford Ranger edge 3.0 flex ... Truck was running fine and giving me no issues. I woke for work the other day and went to get coffee and truck wouldnt start. I could hear fuel pump running and knew it wasnt that, it was acting flooded. So today I pulled fuse from fuel pump relay, and got it to start. Put the fuse back in and ran to gas station. On the way to the gas station it started running really rough, very low and rough idle, trying to stall out. I noticed it had black smoke coming from exhaust. I got it home, and got it to start barely, and it has the same very low and rough idle, but my oil gauge was going crazy, flickering back and forth all crazy, and the idol is terribly rough and eventually stalls out. Earlier today I did put new spark plugs in it, but not sure that has anything to do with the issue. I also hooked it up to a computer and it isnt throwing any codes.
View 13 Replies
I have a 2004 Grand Caravan 3.8 engine. For the last 2 months the oil light has been coming on when car is first started. If I stop engine and start again the light will be off. I don't think its actual oil pressure because the car runs fine with light on or off. I'm thinking a bad pressure sensor?
View 17 Replies
Sometimes when I start my 2006 Dodge Grand Caravan, 3.3 liter engine, the oil light comes on and stays on, even if I rev engine up. Engine sounds normal, does not sound like oil pressure is low. If I turn engine off and the immediately back on, light goes out and stays out. I replaced the oil pressure sending unit - didn't work. I hooked up a gauge - engine has 60 psi oil pressure at idle - plenty! I'm guessing an electrical problem in the circuit.
View 4 Replies
I have a 2005 Grand Caravan, this winter has been a cold one. The GC has always started without problem but after I back out of my parking spot, it sits outside, I put it into Drive and it will not move and after I give it a little gas it would still not move. None of the gears seem to work, but if I wait a little bit and the Van warms a little more it will go into gear and all is good. This does not happen all the time and when it does go into gear and I drive I do not have anymore problems until the next time it will "act up" on me again. Is this a problem or is it a cold problem and not a transmission problem?
View 7 Replies
