Corolla / Matrix 2009-13 :: Engine Rattle Always Happens On A Warm Restart
Apr 15, 2010
I finally caught my engine rattle on audio. Give a listen and tell me what you think this is: [URL] .....
There's a TSB about a rattle on a cold start, but mine never rattles when it's cold. This always happens on a warm restart -- usually about 45 to 75 minutes after I've parked it.
It's been doing this for at least a year, but I've had trouble catching it in the act and, of course, the dealer can't reproduce it. I currently have 37k miles on it. Oil changes completed at 1k, 5k and every 5k after. Using Mobil 1 5W-20 since the second change.
View 14 Replies
Advertisement
2009 Matrix 2ZR-FE, briefly rattles on restart after sitting for one hour after reaching running temp. This engine doesn't rattle on a cold startup so I'm wondering what else other than the intake cam gear could cause this. 42,000 miles, 5-20 dino, regular service.
View 14 Replies
I have a 2010 corolla with 32k miles, automatic transmission. I have an intermittent low idle issue when it rained or when it is below freezing 32F. It happens when I am in drive and about to brake to a complete stop. The idle dips to around 500 rpm, the engine shudders and the car shakes then after a second or two, the engine idle goes back up to 800 rpm. There is no engine concerns at any other speed just at idle. I have no CEL codes. The engine never stalls. Low idle when braking.
View 1 Replies
I finally pulled the trigger on a dark grey Corolla S yesterday, and it turns out that it rattles on the driver side top dash. When I push on it, it stops, but it's pretty annoying and noticeable. I guess I should take it back.
View 14 Replies
I have a 2010 Corolla LE with approx 63k miles. The problem I am having is when approaching about 45 mph, a slight rattle begins to make noise and it gets faster/louder as my speed increases. It is a noise that sounds like something is vibrating on the inside of the dash/in the engine bay. I have opened up the glove box and replaced the cabin air filter, and even drove around with the glove box dropped down to see if the noise is coming from the interior. It sounded the same with the glove box dropped down. I have done research with the service bulletins and even secured the washer hose suspecting that was the problem but it made no difference.
It is very frustrating to me because it does not seem to be affected by anything but speed. After hitting 45 mph it begins and will go away after going below 45. Changing any of the AC/blower knobs makes no difference. It does not seem to change the way the vehicle performs in any way either. Just an annoyance more than anything!
View 3 Replies
I posted a few weeks ago about the 2009 Corolla XE that I purchased from a Toyota dealer with 95,500 miles. Within days a buying the car it began to make a brief loud rattle on cold starts. People on this forum directed me to the VVT and they were right on. The car came with a 60 day warranty so they replaced the timing gear at no cost to me problem solved.
Now several weeks later, last night when I got out of the car with the engine running I heard a pretty loud noise that sounded like one valve very out of adjustment. This morning when I started the car the noise was no longer there but when I checked the oil it was a quart low. I have put about 1800 miles on the car since I bought it and the oil was changed at the dealer right before I bought it. I thought it being low on oil might be causing the noise. I took the car to the dealer and explained everything, the put a quart of oil in it and said to bring it back in about 1000 miles to check it out.
When I got back home the noise was there again so I guess being low on oil wasn't the cause. In terms of oil consumption the service rep said Toyota considers up to 1.1 quarts per 1200 miles to be normal oil consumption. This sounds like a lot to me.
And in terms of the noise that sounds like a loose valve I'm beginning to think it had something to do with the work they did to replace the timing gear. What would make this noise come and go? Doesn't seem to be any relationship to operating temp or how long the engine has been running.
So I guess I have two problems, potentially an oil consumption problem and a intermittent loud noise that I don't like the sound of. My power train warranty expires Nov 19.
And do the valves on 2009 are adjustable, the service rep said they were auto adjust?
View 9 Replies
My son's 2010 Toyota Corolla S made a "rattling ticking sound at idle" twice this week.
I can't duplicate it, the oil level is fine and everything is working.
View 4 Replies
Dashboard rattle/squeak noises in the 2013 TOYOTA COROLLA ZRE182R ASCENT SPORT S-CVT. I purchased this car in Feb 2013, brand new.
A rattle began to develop around the dashboard area. At first, it sounded like a rattle on the left side of the dash near the aircon vent. It took two visits to the dealership service center to repair the rattle.
Within a week of the second visit, the rattle came back - this time in two places, and much worse. The second rattle noise appears to be coming from behind the wheel. Hard to describe the sound, it's more like a high pitched squeaking rather than a dull rattle.
To date I have had wires/brackets either replaced and/or tightened, and also foam applied in numerous places. Still, the rattle persists.
View 2 Replies
I've owned this vehicle for the past year. This 2009 Corolla XRS manual has a very annoying steering rattle which took me the whole year to finally breakdown and diagnose. There are many forums stating this rattle is associated with the intermediate shaft assembly #2. I did end up replacing this part 45260-02110, hoping this would fix the rattling or knocking issue. It did not, but smoothness the steering has improved. I removed the upper portion of the intermediate shaft to pinpoint the sound. Originally I believed the noise may have been coming through the bulkhead from the intermediate shaft #1 or steering rack. I checked under the boot and everything was snug. Then I rattled the steering wheel around and this what I found.
It seems the noise is coming from the pinion where the power steering motor meets the steering column. You can hear the knocking noise with settle steering wheel movements. As I move faster, the knock turns into a rattle at higher speeds most likely vibration from the road. At this time, I do not want to disassemble the whole column just to see if I can adjust the motor height (if possible).
YouTube : [URL] ......
View 6 Replies
I have a 2011 corolla S with 32.5k on it, so my 3yr/36k warranty is running up in a few months. my car from day one (that I had it, at 17k)has had an annoying rattle in the headliner ahead of the sunroof, near the overhead lights. If I press up, even slightly on the lip of the headliner around the front of the sunroof cutout, it goes away. Dealer thinks its normal and says repairs wouldn't be covered under warranty.
The second is a new one, when I go over a bump in the road at highway speeds, there is a squeak coming from the center of the dashboard, at first I thought it was a strut, but after driving back and forth on the same stretch of road for half an hour, I found it to be coming from somewhere behind the radio. Dealer says, squeaks will happen as a car ages.
Do I need to take it to a new dealer (about an hour away) or can I fix this myself?
View 6 Replies
I have a 2011 corolla. the engine just dont have any pep. is there a way to swap 1.8 for a 2.4 . is it worth the effort. or how can i get more pep without sinking lots into it.
View 14 Replies
OK all sensors and evac valve done. No codes being pulled. No check engine light. Car starts no problem in the morning or when its been sitting but when the car has been driven to temp. I will not restart and just keeps cranking, if it starts to start it shudders and dies. I am the original owner and its had any maintenance its needed.
View 4 Replies
I own a 2009 superwhite corolla xrs. I've owned the car now for several months . Ever since I got It, I've heard a noise coming from the engine bay . Sounds like a Metallic rattling .seems to do it in the cold and warm weather . I have a feeling that its the water pump . Every time I take it to the dealer it doesn't make the noise. It's makes the noise on a regular basis . Check out the video... ignore the dirty dash low fuel light... I was parked by a gas station i swear.
View 3 Replies
My daughters 2009 will start right up but after about a second it shuts right off we tried it several times and it shuts right down.If you wait for 10 to 20 mins it starts and runs fine.
View 4 Replies
My 2009 , 1.8 Corolla gets terrible gas mileage. 23 city (lowest was 12), best ever was 30 highway. I have approx 14K on the odo because the MPG makes me want to leave at home.
The MPG has been verified in writing by 2 different dealers, so I do not consider myself the problem. I drive conservatively and calculate MPG based on actual miles / gallons. Toyota Corp did not bother to fix this issue. It has been serviced regularly and had whatever fixes Toyota offered.
What I think is causing my terrible mileage is some glitch in an engine sensor that causes it to rev from 900 to 1100 RPM when I take my foot off the accelerator and attempt to coast. The revs go down when I press the brake. This happens constantly, especially at around 25 MPH. If I do not brake, the car will pull for a while without slowing down like normal cars.
I showed my Toyota dealers but they all said nothing is wrong. My Corolla even went up a slight hill without my foot near the accelerator. One tech told me the Corolla is burning off extra fuel, but my car will pull itself for over 1/2 mile, too much time for "burning". Something IS wrong. I have driven dozens of vehicles and never had one jump like this. Where to start diagnosing?
View 14 Replies
My engine just went out in my 2009 Corolla XRS. What vehicles have the same engine as a 2009 Corolla XRS 2.4L manual transmission?
Also, what would it take to put in the 1.8L engine? Would it bolt straight up? Would I need a new ecu/wiring harness/mounts/exhaust/trans etc?
I am considering putting in a rebuilt or used transmission at the same time because my syncros were failing.
View 14 Replies
A couple weeks ago, my check engine light popped on and I noticed my engine misfire. I happened to be driving by an autozone, so I pulled in and had them check the code. Came back as a misfire on cylinder 4, possibly bad ignition coil or clogged injector. I ran some techron for the next couple of gas tanks, didn't seem to do much, as I would still occasionally get the check engine light.
It has been getting more and more common for it to happen while driving since. Today on the way home from work, it misfired several times in a row and got so bad that I couldn't get above 40mph. This lasted for a minute or two, then cleared up and I made it home without a hitch. Took it back to autozone, same code..Cylinder 4 misfire, probably ignition coil or primary/secondary ignition b fault. I went ahead and bought an ignition coil, came back home and installed. Just took it for a test drive and now I've got the same issue.
I only replaced the one coil that has been throwing a code as misfiring. I did not also replace the spark plug on that cylinder.
View 6 Replies
Just purchased a 2010 Toyota Corolla S, 41k, automatic. When I'm going down a flat road, at about 30-35 miles per hour, with a constant pressure on the gas pedal, the engine seems to momentarily lose RPM, just for a moment, almost feels like the A/C compressor is kicking in but not quite, another description is it feels like clogged injectors. All other speeds seem to be ok, kicking the throttle to the floor results in smooth acceleration, I'm actually impressed with the amount of power the engine has. Is this normal? Ive purchased some lucas fuel treatment and have added it to the tank. Throttle response seems ok, I've read about throttle controllers however I'm not sure that would fix the problem, if there is one. Hoping it's a characteristic of the vehicle.
View 10 Replies
I have a 2009 Corolla 1.8L. It turns over but won't start. I don't hear the fuel pump when I turn the key on or when I try to start it. There are 3 EFI fuses, and all of them are good. There doesn't seem to be an EFI relay (correct me if I'm wrong). I've replaced the fuel pump and it still won't start.
View 10 Replies
Installing a remote engine start on corolla? 2013 Corolla with G key specifically.
View 13 Replies
I now have 500 Miles on my LE. Driven soft Never over 2,500 rpm except, one time I accelerated to 4,500 RPM in first. Short 5 Mile trips.
Engine knock on start-up (Lasts one second)
sounds like a lifter pumping up.
Only happens occasionally.
Happened last night after driving 40 Miles and parking it for two hours.
Is this normal? I have noticed this since the first 10 Miles on the odometer. Figured it was the 0W-20 Oil.
My friend has a 2003 Echo with 100,000 miles and it does not do this.
View 12 Replies
