Chevrolet - Tracker :: Loud And Constant Squeal When AC Turned On
Aug 17, 2014
2003 Chevy Tracker (same as Suzuki Gran Vitara) v6 2.5L
For about a year, it has had belt squeal on starting, which lasts about 5 minutes..it's louder when AC was on..would go away with higher RPMs. Once the car was warmed though, no squeal. Ac has been working very well and blowing cold whole time. Finally it around to replacing belt, which was a difficult.
Tightened with an idler pulley type system(not spring loaded). Started it up, squealed a little on start, but went away..turned on AC and the squeal is horribly loud now and constant..high rpms only make it louder. Noticed that clutch engages fine, but spins inconsistently..like we'll the belt is slipping. It spins slow, fast, slow..etc. I can't tighten anymore as the tightening bolt is at the end of the channel, don't want to strip it. Also noted that it is about a bolt head width more tight than its previous position.
Surely changing the belt wouldn't cause the clutch to bite it would it?
Other notes...drives great when ac is not on. This is an acc only belt..ac,idler,power steering. Also, during the repair, antifreeze got on the pulleys..I cleaned them all around with generous spray of brake cleaner..they look clean.
View 19 Replies
Advertisement
1997 Ford F150, 6cyl, 138K miles. The truck has a loud squeal when the wheels are turned. This occurs when it's stopped or at low speeds (can't really tell if it's happening at other speeds ?). A friend who's a mechanic, upon hearing the noise, said he thought it was either tie rods or ball joints. I replaced the tie rods (original ones) and the squeal remains. Is there any definitive way to determine if indeed the ball joints are causing this noise ? When I posted before, someone suggested I may have a bad serpentine belt pulley, but the noise seems to be coming from the front end, and not under the hood.
View 6 Replies
My 2000 Chevy Tracker will not go into reverse. Had tranmission drained and cleaned. Still won't go into reverse. Does this model have a separate reverse cable?
View 1 Replies
my 2002 Chevy Tracker has run faithfully for the last 5-6 years. a few things have come up recently that have needed to be replaced, but nothing huge. after my AC compressor was replaced, my car started powering off in the middle of driving (not while revving engine standing still). mostly on cold starts, but now more frequently. mechanic swears it has nothing to do with AC compressor.
But he is checking drive train today. He has changed the tranny fluid, fuel filter, cleaned the gas tank, cleaned the throttle body (IAC motor), cleaned the mass airflow filter sensor, checked the battery voltage in case of an alternator problem. he has scanned the vehicle while driving and sitting still several times and no codes come up.
View 3 Replies
My 2002 Chevy Tracker recently has been running poorly after consuming a 1/4 tank of gas. The check engine light comes on the scan tool reports P0171 and P0174 bank 1 and 2 lean(it's a 2.5 liter V-6). If I remove and replace the gas cap it runs better but not perfect. Once I use another 1/4 tank the symptoms return. I have noticed the cap is hard to remove lately. This has been going on for two weeks It's been to 2 garages one of them told me my catalytic converters are plugged up and wanted 2500 to fix .
View 8 Replies
I have a 98 Chevy Tracker 1.6 auto. My OBD reader shows engine load @ 25% in park at idle. What would cause this.
View 5 Replies
The problem started several months ago. At first it would only happen once in a while and would only last about 5 mins. The first time it happened I had it towed to my shop and it ran fine when it got there. Go figure. They told me they couldn't diagnose it if it wasn't acting up while they had it. Makes sense. But it never does it when I'm there for routine maintenance. Now it's doing it for twenty minutes at a crack. It's usually fine around town unless I get stuck in stop and go traffic. When it usually acts up is when I get on the road between work and home.
Every time I stop for gas I have to wait for it to decide it wants to start again. All of this is putting heavy wear on my starter. I changed the oxygen sensor (position no. 01), because that was the only error code that showed up. That didn't fix it. My mechanic says he thinks the next best step might be the cam and/or crank sensor. If not that, then he thinks we should change out the brain. Somebody else said it might be the fuel pump goin out. because I travel too far for work and I can't afford to fix things that probably won't solve the problem.
View 1 Replies
I have an '02 Chevy Cavalier. It was making a screeching noise when I turn for a while and now has started making a loud rythmic clunking noise all the time when the car is turned on. It gets louder and softer but never goes away. It is coming from the engine area.
View 4 Replies
For 8 or 9 months now the dash lights and headlights on my 2001Chevy Tracker are dimming (more like flickering but they don't go completely out). It is not the alternator - it has been checked. For a period of 4 orso months in between the beginning of this and now - the dimming stopped and now it's back. The only thing I can correlate to the dimming stopping was I had to have my car jumped because I left the headlights on and the dimming seemed to stop for the long period of time.
View 1 Replies
98 tracker with 5 speed manual transmission has new clutch pressure plate throwout bearing and shit cable. strictly mechanical clutch mechanism drive for about 30 minutes and clutch goes away and unable to shift gears. let it sit overnight will work until about 30 minutes of drive time when everything has a chance to heat up...
View 8 Replies
I'm having trouble with the headlights on my 2003 Chevy Tracker. When it's light out, my headlights come on automatically when I release the parking brake, but turn off if I turn the switch that would normally turn them on. When it is dark out, or I drive under a bridge etc, they turn off and I can't manually turn them on. I can "flash" my headlights, but if I turn them on as if to leave them on, they don't turn on. This problem started about the same time that my AC blower stopped working, so I replaced the blower motor resistor and all fuses (I've heard that the blower motor resistor is also involved with the headlights). This fixed the AC, but had no effect on the headlights.
I can trick the lights into turning on at night only by shining a bright light directly on the sensor - they turn back off as soon as I remove the light. I took it to Pep Boys for a basic electrical diagnostic to see if I might be missing something silly, but once I described the problem they wouldn't even bother - told me to take it to the dealer and have the body regulator module reprogrammed.
View 8 Replies
2003 Chevy Tracker 4 cylinder. Engine rebuilt and cannot get lifters to quiet down. Replaced 3 times. Bent valves on first install.
View 3 Replies
I drive a '99 Chevy Tracker with the 2Liter engine, a 5 speed manual transmission and 110K mi. on it. When I lift my foot from the throttle pedal in preparing to shift gears the engine takes a very long time to reduce it's RPM. This is a problem, when up shifting, as the transmission is spinning too fast for smooth gear engagement.
The engine idles normally under all other circumstances. It is only slow to decelerate whenever I lift my foot from the throttle pedal. This makes up shifting very slow and/or causes the gears to sometimes grind slightly.
View 3 Replies
I have an '02 Tracker and I've noticed if I have several accessories running, that my engine will start to sputter and come to the verge of stalling when I come to a stop. It happens if I have the heat/air and radio or charging my phone on together. What is the cause and/or remedy for this? I've changed the alternator a few yrs. back, but it still continued.
View 2 Replies
2001 Accent 1.6, A/T. Just replaced alternator myself. Checked and adjusted all three belts; all seem tight. Now I have a belt squeal. P/S fluid is full. When car starts there is no squeal. 15 seconds later chirp starts. A few seconds later squeal is constant and remains throughout entire ride - except when I make a turn. During any turn squeal goes away, then comes right back.
View 8 Replies
Further investigation I figured it was the the flap opening and closing. Whenever I push the recirculate button to open and close the vent it squeals. Is there a way I can lubricate the vent?
View 7 Replies
I have a 2002 Chevrolet Cavalier that recently is having a/c and engine problems.One problem is that when the a/c is on the car will idle very badly- possibly varying 300-400 RPM. It will do this until the air is turned off or it is given more gas.The second problem is when trying to keep the car at a constant speed with the a/c on the car will vary 200-300 RPM until the a/c is turned off or it is given more gas.The last problem is when the a/c is on and no more gas is given to the car the a/c will start to blow out hot air. However, when gas is given to the car (probably has to be at about 1500 RPM) the a/c will blow out cold air. The car is a 2.2L 4 cylinder. The car has had the check engine light on in the pass but I had cleared it (it was the o2 sensor) several times. But recently it has not been coming back on. I don't know if this has anything to do with it, considering it only happens with the a/c on, but I thought that I would mention it. The car runs fine without the a/c on (idles well and drives good at constant speeds).
View 7 Replies
Have a 2004 Sport Trac with approx 78,000 miles. My daughter drives the vehicle around town. Approx. 2 weeks ago when she started it a loud squeal came from under the hood. I raised the hood and determined it was coming from the serpentine belt. I sprayed some lubricant on the belt and the sound went away, temporarily. I took the vehicle to a local mechanic. He thought the belt needed to be replace and did so. He showed me the old belt and commented that the old belt was in great shape and he could not determine where the sound came from. He also was able to spray lubricant on the belt and make the sound stop for a while. The squeal is definitely rpm related and also gets louder if the heater/ac fan is turned on. I have been reading alot on the internet about such problems with this vehicle and am getting really concerned. If it were the harmonic balancer would the vehicle still be operating this length of time since it started making the noise? What does replacing the harmonic balancer involve.
View 8 Replies
Sometimes (but not always!) when I turn my Prius (2008) off and open the driver door, there is a constant beep. There are no interior lights left on. I think whatever I am doing wrong might be draining the 12v battery as it keeps going flat.
View 4 Replies
Fuel mileage dropped from 52 to 40 on several hot days and I heard a constant loud hum. In the shop tomorrow.
View 19 Replies
I have an 02 Elantra GT. I was dropping off a friend who knows cars and went to turn around, turned the wheel to full lock to make the turn and heard a squeal. I asked my friend what it was and he said it was the P/S and I just needed to add some P/S fluid. I got some fluid and sure enough when I went to fill up the reservoir it was below to MIN line, not too much below but still below it. I filled up the fluid and didn't hear the problem for the rest of the day but this morning I heard the same noise when I was leaving for work. I figured the fluid had to work its way though but am not sure if there is something else I should check or do.
View 3 Replies
