Chevrolet - Cavalier :: 2004 - Rattling Noise When Turned On
Apr 28, 2013
Last week my car started making a rattling noise whenever I turned it on and when I went over bumps or potholes in the road. It sounded like it was coming from the trunk latch or something. It also started squeaking- I knew it wasn't my breaks because I wasn't using my brakes when the squeaking happened. I finally realized my muffler is jiggling around, so I crawled under my car to check it out. There's a part on the left of the muffler right by the rear tire that connects the muffler to the under side of the car. It looks like something is missing- rubber or something that holds the pieces of metal there. Is this something I can find and fix myself? Or do I need to go to a mechanic? I was going to zip-tie it up, but there's not really anything to loop it through. Will my car be further damaged if I don't fix it soon? (2004 Chevy Cavalier)
View 4 Replies
Advertisement
I have a 2001 Cavalier 5-speed manual 2.2. I have owned it for every day and every mile (204K) since I bought it new in April of 2001. I have had many mechanical disasters and problems mostly starting a couple of years ago - and a lot of them I have worked on or fixed and/or replaced the part myself.
The transmission fluid in this car has never been changed, looked-at, drained, added, etc....because I was told that it didn't need it. The manual says the same thing. For as long as I've had this car, it has had a intermittent rattle noise that I figured was just the "Getrag rattle" - so I didn't pay much attention to it. But over the past year - especially the last 6 months - this rattle has just gotten totally insane and out of control. It is now a constant loud rattle whenever the car is in gear - especially starting out in 1st or 2nd. I mentioned this to someone and they asked when the last time the fluid was changed and said that would fix the problem - and couldn't believe that the fluid had never been changed after 15 years and 200K miles.
This model has no dipstick. There is a big red vent cap and I think I found a HEX plug close to it, but before I go out and buy the wrong size hex key - what size these are and if they are even what I am looking for to fill/check/drain it? So frustrated. Also - since I can't find DEXRON 3 anywhere am I supposed to use this DEX/Mercon stuff?
View 19 Replies
I have an '02 Chevy Cavalier. It was making a screeching noise when I turn for a while and now has started making a loud rythmic clunking noise all the time when the car is turned on. It gets louder and softer but never goes away. It is coming from the engine area.
View 4 Replies
I've got a 2004 Cavalier and when the heater is turned on it makes a clicking noise (sounds like someone on a snare drum playing over and over again) You can feel it if you touch the bottom of the Heater/AC module on the passenger side of the car above your feet. It stops when you turn the heater control to the recirculation position.
My guess is it's the recirculation door actuator motor, but I can't find it through NAPA or any automotive parts online sites, what the Chevy part number is for this, and/or a parts blowup of the HVAC module? Also, the factory service manual I've got says that the entire HVAC unit needs to be drained of 134 and removed from the vehicle to replace this actuator, does it can be done without removing the entire unit? From the few pictures it shows of where the actuator is, that part appears to be near the top (that's why I'd like to see a parts blowup if possible).
View 9 Replies
So I have a 1999 Cavalier..I drove it yesterday without issues but when I got up this morning to go to work, I turned the key to start it and it seemed as if there was a boom from the engine. The engine didn't start, but when I tried the key again, it started right up. I drove 35 miles to work, including some highway miles at 70 mph. What would that have been? Is it a sign of things to come?
View 13 Replies
I have a 2004 Chevy cavalier with 133,000 miles. For the last week I have been hearing a ticking noise - seems to be coming from inside the dash board on the passengers side (glove compartment). The ticking noise begins when the engine starts up and stops when the engine stops, so the noise is continuous while the engine is running. The car runs well, no loss in power, nothing out of the ordinary, with the exception of the noise. I opened the hood and listen - the sound seems to come from inside the firewall.
View 5 Replies
My airbag light flashes six times when I turn my car on. Then it remains on while I'm driving. I have no clue what this means.
View 4 Replies
Car won't start after filling up with gas. I have tried a new fuel filter, new gas tank cap, checked for pressure on fuel pump. We have gottenit to start (but barely) when either hit gas tank with hammer or shake the back of the car, otherwise you have to set and wait 15-30 minutes before it will start and when it does it smells very weird (like it's flooded but an extra strange smell with it). I have seen a similar posting on here and someone suggested it might be a purge value problem. In talking with someone at auto store they didn't think this was the issue. I do have my check engine light on all the time and when checked the code , it said oxygen sensor. My two other Cavaliers have also had the oxygen sensor problem but it never did this with that code.
View 9 Replies
I have a 2004 Chevy Cavalier. I am having some issues with it.
When it first starts it idles really hard. The RPMs are up and if will try to accelerate without hitting the gas. This stops after the first minute.
The second part is that when stopped, but in drive, it idles hard. It does it though when the AC is turned off. You can see the RPM gauge go above and below the normal 500 RPM. If you turn the AC on then it levels out. It will occasionally idle hard with the AC on, but rarely and not as much.
The car drives well and is not overheating.
View 3 Replies
I have a 2005 Chevy Cavalier and have been realizing that the ride has been getting noisier, but when I make a left hand turn ( or even turn the wheel 5 degrees or so to the left) it is much quieter. It sounds like a low vibrating sound and seems to shake the whole front end of my chassis. I can feel the vibration through the gas pedal, and it continues even when in nuetral or without the gas depressed. It is worse between 40-65 mph. Loose parts, misalignment, motor mounts, bad belts? And what it might cost to have this fixed?
View 5 Replies
So i went to put my car in gear and the clutch is loose. car turns on just fine. there is clutch fluid. I've never had this problem till this cold weather popped up.what do i do? wait till the car warms up? I can put it in gear when the car is off so idk why it does that.
View 8 Replies
My future mother-in-law has a 2004 Chevy Cavalier. Last night night when she tried to put it in gear, the car would not go in reverse or drive. She recently had a tune-up on her car a month ago and everything seemed to be working fine. I think the transmission is dead. Does that sound right?
View 8 Replies
Lately my 2004 Chevrolet Cavalier will overflow gas when filling up completely. It does not make a difference where or what type of pump is used. The auto shut off on the pump clicks and stops the gas. Then 1-2 seconds later gas spewes out of the filler hole. Putting about a half gallon or more of gas on the car and on the ground. What changed and how to fix it? The GM dealership doesn't know and neither do other shops. Here's a video : [URL] ....
View 10 Replies
I have a 2004 Chev Cavalier with a 2.2. Ecotec OHC. Lately the car has started to stagger on acceleration. Particularly when going up hill. The weird thing is, it only does it after it's been running for 10 or 15 minutes. Up until that time it runs smoothly. But when it happens it feels like the engine bucks. Or hiccups. If I stomp on the gas the car will either stall or kick in and overcome this. When I'm driving down the road at a steady speed, or when I'm sitting still the engine will buck in the same fashion. Not steadily--intermittently. Once or twice every fifteen seconds. But it's getting progressively worse.
Now if I launch out of an intersection the car might even stall. When this happens I just turn the key and she fires right up again as if nothing happened. No "Check Engine Light" or trouble codes showing up in my Scangauge. I replaced the fuel filter just as a preliminary measure but that didn't solve the problem. I had the fuel pump replaced a few months ago as well but that ws before this problem occurred. No other parts or pieces replaced. Fuel pressure regulator? Spark plugs? Injectors?
View 5 Replies
Like I said, 04 cavalier automatic.. Bought it used over 200thousand miles, but in PERFECT SHAPE, engine is beautiful.. No leaks that I could tell from the ground. Just put on new rotors & breaks,.. Now the problem.. under neath my petals sounds like doo doo doo doo, like a really big fan, & Its hard to accelerate at 35-55mph.. When i do it has to like catch up with itself, as if not going into 2nd gear.
I know nothing about cars, so I am describing the best i can.. Its also been sucking gas like crazy.. but no leaks? All my lights are lit up.. ABS trac off, service, & check engine. One guy said the noise is someone impacted on my aluminum rims too tight & they could be bent, it was very hard for him to get my tire off to change rotors..
View 5 Replies
I have a 2003 Chevy Cavalier. When I'm going at some speed (not from a stop) to the left (like on a curve), I hear a high-pitch squeaky/squealing noise. It's not one long continuous noise, but more like chk, chk, chk, etc. and high in pitch. It doesn't happen when I'm going to the right. And I don't hear it if I'm going very slowly, such as turning left from a complete stop.
What this might be?
View 4 Replies
I have a 97 Chevy Cavalier, 2.2 ltr, that started giving me problems last week. I was going to leave the house and got a bout 50 ft before I heard a "tink" noise and it died. It won't start now. I have checked everything that I can think of. It's not a rod or anything like that. It has to be something really simple. It will turn over, just can't seem to start.
View 6 Replies
I drive a 2003 Chevy Cavalier with approximately 75,000 miles on it, and it has always run exceptionally well. However, during the last couple of months it has developed what I would consider a lower-pitched "whine" or "groan" emanating from the front of the car when making a turn. Here are a few specifics:
-The noise is more pronounced on tighter turns and/or when moving at a faster speed. For example, doing a U-turn causes the noise to be very pronounced; turning into a parking space at a very low speed barely creates any noticeable noise at all.-The noise seems to be worse when making a left turn than when making a right turn, however turning either direction can create the noise.-The noise seems to have gotten slightly more pronounced over time--that is, it doesn't seem to have been triggered by a single event such as running over a pothole.
I am not particularly well-versed in diagnosing car problems, particularly when it involves anything to do with the drive train (which is what I suspect here). Some rudimentary internet research seems to point towards a damaged or failing CV joint in one of the front wheels, although this has not been properly diagnosed. Thus, my questions are as follows:
-What is the likely source of the noise? Is a damaged CV joint the most likely explanation, or is this explainable in other ways?-How serious of a problem is this? If indeed it is the CV joint, my understanding is that this is an issue that needs to be addressed promptly as it could quickly become a dangerous situation (some reports indicate that the wheel(s) might come off while driving).
View 7 Replies
A rubbing sound that began with lower temps (winter here). It occurs when going over bumps - even small. Does not occur at highway speeds. Gets quite loud. Does not have to do with steering or heat as far as I can determine. Some times does not occur at all. Don't know if any relation, but recently the dome light is coming on when coming to a complete stop.
View 1 Replies
I just purchased an 05 cavalier and today a loud clicking noise started right down by the glove box. I have full a/c and heat. If I turn the climate control to recirculate the clicking stops. But now the orange engine light is on. I've heard it could be the blend door actuator from what I've read online. Would this cause the engine light to come on? The code reading from autozone was coolant leak/coolant low/thermostat something along those lines. But the engine light came on 3 hrs after the clicking started so I am thinking it's related.
Oh also (the clicking stops after the car warms up a bit)? I would love to just buy the part online and have a small place replace part. I cannot afford hundreds of dollars in labor. If that is the right part does the dash need to come out in an 05 Cavalier or can it be gotten to under the glove box?
View 17 Replies
It looks like the door jamb switch no longer pops open so I am wondering how in the world do I replace it? Someone suggested grabbing pliers and just pulling on it till the tabs break off and it comes out. Is this the correct way? This is a 2004 Chevy Cavalier and some of the symptoms of my problems include the radio not turning off when you open the door after getting out of the car. Nor do the dome lights come on when I open the door to get in.
View 7 Replies
