Chevrolet - Cavalier :: 1998 - Overheating After Installation Of New Water Pump And Thermostat
Nov 30, 2014
I had a leak in my water pump so we had it replaced and a new thermostat. Now it is overheating in just about 2 minutes and my heater is now not working. I was told that it is most likely an air pocket in the coolant. I have let the car heat up, not to the point of hot but over half way and shut it off, taken the cap of let it sit for a while and then trying it again. No luck so far. Is there another way to get it out of there? and would the cap have anything to do with it? it has been hard to take off in the past and now its coming off easy. It is the plastic kind. I am at the end of my rope here . the car runs like a dream, its just this one thing.
View 12 Replies
Advertisement
My son has a 2002 Jetta, we just changed the water pump and the thermostat. The car will sit at idle and the temperature will stay around 190. When you drive down the road the temerature will rise and when you let off teh gas the temperature goes back down. What this could be, I have tried everything I can think of to fix this car.
View 13 Replies
I was checking under my hood today and I happened to notice a dent in what I think is my water pump. Should this be cause for concern or something I can just ignore?
View 16 Replies
I have a new thermostat and a new water pump. Why is my car still running hot?
View 4 Replies
OK, we have a cavalier that is slowly dying but until we find a good price on a used car we are looking at it has to keep chugging along... It started to overheat about month ago, just when you go up a hill otherwise it is fine (doesn't overheat but a few lines from the red zone!). Mechanic said it was a head gasket and we have noticed that the coolant level is down slightly... can it be a head gasket yet still drivable? Also about 2 months ago the car needed a new water pump, flushed and filled, could it just be the new water pump was bad? No other issues, heat works fine, no puddles under the car etc....
View 14 Replies
Ok so my car kept overheating and I saw I had a small leak from the gasket on the water pump. I replaced the water pump and gasket but then it would zoom straight to overheating. I then assumed it was a stuck thermostat and replaced the OEM with a fail-safe thermostat. After topping off fluid and leaving the radiator cap off until I saw fluid running through it took it for a drive. The temp began to climb to overheating but dropped just as it was getting to the red and then began to fluctuate. Finally heat came through the car climate system and all was good until I had to come to a stop. It seems that whenever I have to stop at a light the temperature rises to overheating.
View 9 Replies
I have a 2002 Caviler. Somewhat recently the car has been not staying at a constant temperature. It will rise above the middle (where it would always just stay at until recently) a notch and then go down a notch below the middle. I have never replaced the thermostat and I have had it around 8 years and the car has around 60,000 miles. Did replacing the thermostat fix them?
View 7 Replies
problem is the my 1998 Legacy (142K) overheated this past weekend. It shut off and I had it towed to a "new" mechanic around the corner from my house. He diagnosed the problem as being a faulty thermostat. He replaced the thermostat and returned the vehicle to me. Two days later my wife was driving home and the car had a major overheating incident with resulting serious mechanical failure. I did a little research and within about five minutes found that this problem is quite common for this car and is more commonly related to a head gasket issue. My question is should this mechanic be held responsible in any way for the misdiagnosed problem? If so, what would be the best course of action? The car was otherwise running fine and in fact I recently had the transmission rebuilt.
View 3 Replies
1995 Ford Van E150. So I've been trying to solve my overheating problem for months now. One morning I walked out of my house and all of my coolants was on the street. I could not completely detect the source of the leak after running more coolant through it. I also checked the dip stick and coolant on the ground for any sign of oil/coolant mixing. I started by replacing the thermostat.
I did a more thorough inspection and found a crack at the bottom of the radiator that I replaced less than two years ago. I replaced the radiator again and while I had the belt, intake and fan disassembled I switched out the water pump as well. The old water pump was gunked and the gasket was almost completely worn off. The van is still overheating and spitting out coolant at a much higher rate. I'm guessing because of the new water pump. A friend said it could be the intake manifold because of where the steam was coming from the motor.
View 5 Replies
My son has a Mustang GT 5.0 that is overheating. I replaced the radiator with a heavy duty 3 core radiator. It had underdrive pulleys so I replaced them with stock pulleys. I put dual electric fans on it. I flushed the block and put a new thermostat and replaced all the hoses (made sure the bottom radiator hose had wire in it so it wouldn't collapse). I put a new water pump and drive belt but it still overheats when sitting in traffic and overheats when driving with the A/C on.
View 14 Replies
I have a 2002 Audi A4 1.8T with 85,000 miles. Recently my car started overheating, I replaced the water pump, thermostat, and timing belt. The mechanic also ran tests to make sure there were no issues with the head gasket, those tests came back saying the head gasket was a-ok. Yet, my car is still overheating but only on days when the outside temperature creeps above 90 and I am in stop and go traffic. I have to re-fill the coolant tank about once a week depending on how much I drive. I find no coolant puddles under my car when it is parked, so I do not believe it is leaking. What else could be causing my car to overheat?
View 2 Replies
the only thing that is left to replace would be the radiator?my truck is a 1994 f150 and it is not overheating!i get lukewarm heat only on the highway,everywhere else it is cold air!!this new england weather is killing me
View 10 Replies
My 1994 chevy cavalier is overheating mainly on hot days and when I work the engine hard. My coolant level hasn't dropped in a long time and the coolant cap is usually dry. I replaced the thermostat and checked the radiator hoses. They seem to be fine. My engine is leaking coolant.
(See photo) : IMG_2308.JPG3024x4032 2.61 MB
View 19 Replies
So I tried to replace my thermostat and housing and the housing bolt snapped off. Ok so I tried to extract that bolt off and the extractor bolt snapped off inside. I am guessing it might just be easiest to replace the water pump now? I am pretty much at the end of my mechanical rope which is short anyhow.
View 6 Replies
I have a 2002 Chevy Cavalier that stalls ever time it is fueled at the pump. It then continues to stall. I have to pump the gas like the old days when we all had carburetors and repeat the action many times. It always starts eventually, but causes unnecessary anxiety so I always fill my car at a time I don't need to be anywhere in a timely manner. It was taken to the shop but they could not reproduce the stalling, as they did not have the information that it mostly happens at the when fueling. The gas cap can be taken off for a while and it starts okay. The rpm is low after adding gas, if you give it gas, it runs then eventually idles normally.
View 6 Replies
My sister has a 98 chevy cavalier and it is sputtering i changed the fuel filter but that did not work.
View 6 Replies
My girlfriend has a 1998 Cheve Cavalier that recently on the way to work completly blow out the number 3 spark plug. It was completly gone and poofs of air now come out of it's place?
View 1 Replies
i just did a new timing belt water pump kit on a 2001 1.8t (aug engine code) the new pump has a metal impeller. i ran it in the drive way for mots of an hour off and on. figured it was good. took it for a drive and at 5 miles it overheated. Temp Went straight to 260 and stop light came on. coolant could be heard boiling in the system. when i let it idle and ran the heater i got the temp to go back down to 190. but after idling for couple minutes it started going back up. I don't think the stat is bad considering that the heater works which shows that the system is flowing.
View 5 Replies
I just started hearing sort of a howling noise from front end of my 98 cavalier. I also feel a bit of a grinding sensation through my wheel when I start slowing down. I lifted the front tires one by one, checked the play, there's a little on left side and couldn't really feel anything on the right side. I then put the vehicle in neutral and then spun the tires by hand. The right tire spun with ease and the left side was a bit harder to spin. Just wondering if it is the bearings wearing out or if it could be cv joint problems. I also did check the boots on the cv joints for cracks in them but couldn't find anything wrong.
View 3 Replies
I have a 1998 chevy cavalier, 4 door, 2.2 liter SOHC, which has been running hot for a while now. readings are off the dash guage, here's the scenario. on startup from cold, the temperature begins to rise within 60 seconds, reaching what i consider normal operating temperature within three to five minutes, at approximately the "NO" in " NORMAL" on the gauge.
It reaches what has become it's usual operating temperature, at "RM" within another minute or two. If i am in stop and go traffic, the temperature will rapidly reach the final mark after the "L", but not the red zone. If I get on the highway, the temperature will reduce back to the "RM" position within one to two minutes, three to four minutes in steady traffic at lower speeds, i.e. 35 and all green lights. Thermostat has been replaced, water pump has been replaced, electric cooling fan is running correctly, radiator is free and clear of debris.
When I first got the car back in 2000, it ramped up to heat much more slowly, and hung out at "NO" in all types of traffic. in 2004 i went and picked up my car from my father's place, he had taken it to the local shop and had it given the once over, which is when this problem began showing up, and has gotten progressively worse over the years. I've gotten nowhere with other mechanics, the system is leak free, and the coolant tests good.
View 8 Replies
Ok, I just bought myself some problems in the form of a '93 Celica GTS. (5S-FE)
Well, alright, that's a little dramatic. it just overheats. but here's my issue. it's got a new water pump, new radiator, and is still overheating. The guy I bought from says it's in the block, cuased by an attempt to plug a radiator leak with stop leak. He said it just had a minor leak in the radiator, so he put stop leak in it, and after that it started overheating. he's replaced the thermostat, water pump, and radiator since then.
My first question is, could he (and I) be overlooking something? could there be a clog somewhere easier to access? and then if there isn't, how should I go about cleaning out the block? are there areas I should check? anything I should do to try to unclog it? my current plan is to put cooling system flush in (he has some) and drive it home (about 55min. drive) with the flush in it, then empty it and hope for the best.
View 14 Replies
