Chevrolet :: 1999 Truck Won't Restart After Driving At Highway Speeds For More Than 20 Minutes
Apr 28, 2012
I have a '99 Chevy 2500 diesel truck. After driving it at highway speeds for more than 20 minutes and turning it off, it won't restart. The problem seems to be in the battery cable and is definitely heat-related. In cold weather or after a fairly short drive, all it takes is popping the hood to cool off the engine compartment, and waiting. If the engine and/or the weather is too hot, that can take an hour. Then it starts just fine. I've cleaned the terminals and made sure the connections are tight. Two mechanics have looked at it and were stumped.
View 1 Replies
Advertisement
My 2005 Chevy Impala is taking a long time to crank. Now after 10 minutes or so of either idiling or driving, the car stalls out. I am able to restart it. Replaced the battery and no change. Lights are not getting dim in any way so I figure it's not the alternator. Could it be a bad starter?
View 2 Replies
I've got a 2001 Chevy Prizm (160,000 miles) Starts right up-after I drive for awhile and turn the engine off. It won't restart at times - I have to wait anywhere between 5 and 20 minutes till the engine will start again. The engine cranks - so it's not the starter or the battery.
View 4 Replies
I have a 45 min drive to work every day, all highway. Lately on the way home in the afternoon I have been experiencing a surging noise that seems to just happen while I'm doing hwy speeds. It sounds to me like the fan is tuning on and off. Is that possible? It comes on for a few min. And then off again. I have new icp ipr cps. New oil and filter and fuel filter.
Also I'm still having a battery light on and off issue while I'm driving. Is possible the two issues are connected. I plane on doing extensive search for a bad wire this weekend. Batteries and alternator have checked out and are fairly new.
View 5 Replies
when car dies driving or idle- will not start for appx 30min after- cranks over immediately like it wants to, but will not actually start for about 30minutes... is this a sensor?
View 5 Replies
My sons car is a 96 accord. For some reason, it's developed a new problem. After 15 minutes of driving it will stall, and it will not restart. It seems to be if it's left to sit long enough, it will restart(it does crank, just not turnover). That period of time it needs to sit seems more then 10-15 minutes, but we are not exactly certain. After several hours, it seems to start and run fine. We had it towed to the mechanic, they where not able to reproduce it. It's not overheating, the temp gauge stays below half. No check engine light is on.
View 13 Replies
I have a 2010 F150 SCREW with 4.6l 3v 4wd. Up to 100,000 miles nothing more than tires, brakes, and evap purge valve (50,000 miles). Check engine light came on right around 100,000 miles and had no driving problems other than some crappy fuel mileage. Did the following:
Changed evap purge valve, reset cpu by unplugging. CEL came back on after about 200 miles
Took the truck to a shop to get oil change, change plugs, diff fluids, transfer case fluid and get CEL looked at. Shop recommended changing intake gasket as you could see gummy type fluid on passenger side valve cover. When removing the intake found the intake cracked, changed gasket and intake. They reset the light. 200 to 250 miles later the CEL came back on.
Took it back to the same shop, left it with them for the weekend. they think it could be the O2 sensors. I went out and got the shop all 4 O2 sensors and they installed for free (seeing as I spent $2500 with them for all the previous weekends work) 200 to 250 miles CEL came back on
Determined to find time to have another shop look at the problem and trying to get it to a family friend, wasted about a month. At the end of February stopped at a friends house after being there for 20 minutes tried to start truck, it wouldn't fire. It would crank but no fire. Called for a tow and while waiting tried to crank the truck and it fired up, like nothing was wrong. Cancelled the tow truck and drove right to dealership. They determined it was the MAF sensor. Spent the $500 to have them diagnose and change MAF. All things good for about a month and about 3000 miles...
Now in the past 2 weeks it has done the following: I am a construction manager so i am in and out of my truck all day so the engine is never really a cold start except for the mornings when driving to work, it stalled while leaving work on a Friday at low speed. luckily I was able to pull in to a gas station. Tried to restart and it cranked but no fire. after 5 minutes or so tried again, fired up drove home the 35 miles with no problem, truck had power, smooth idle. No CEL.
Same weekend on Sunday, coming home from church at highway speed truck got sluggish, wrench light came on, no response to throttle. Rolled to a stop and then the oil light came on and chime from dash. Turned the key all the way off waited 10 seconds, again crank but no start. Waited 5 minutes and it fired up no problem. Church is only 3 or 4 miles away, no problem going to church, 2 miles into the trip home is when it stalled.
Drove all week, 500 plus miles without a stall or problem
Coming home on Saturday from my kids soccer game again 4 or 5 miles away (no problem going to game) truck stalled at highway speed. Coast to a stop, wrench comes on and then oil light, chimes from dash. Turn key off, wrench and oil light do not come back on. Try to start, again crank but no fire. waited the 5 minutes or so and it fired up fine. (Earlier in the day i got gas, 87 octane, from a one of my regular gas stations from 1/4 tank to full)
Today coming home from church but running an errant the truck stalls after making a left turn about 3 miles from the church at low speed.
All of this without a CEL. What can solve this problem. Clean a sensor? clean throttle body? Gas tank additives? I am due for an oil change and may ask the dealer to look at it but its going to be time consuming as I cant radially repeat the problem and there is no CEL. As I am thinking about the different times it stalled, other than the first time I was probably around 1900 to 2300 rpm.
View 2 Replies
I just bought a 99 f150 it has 257000 miles on the truck, and a motor and transfer case from an '01 with 215000 miles. I'm not sure about the maintenance on the truck but when I'm on the highway the truck randomly stutters. I was thinking it was coming from the tranny because the tranny was overfilled by almost a quart but really not sure.
View 7 Replies
My 1999 Yukon will start up, run for about 5 minutes at idle then die. Then it will not start again till the next day.
I hooked up a fuel pressure gauge to the fuel line at the fuel filter. It started up, and the pressure gauge went up to 54. I gave it some gas and pressure goes up to about 60 then back to 54 at idle. I sat and watched it for a bit then it died after about 5 minutes and the gauge went below 50 to about 48. I immediately tried to start again and the pressure actually drops a little while cranking to 45 and stayed there.
Whats weird is when I first started it up, I can hear the pump come on and it kicked the pressure up from 0 to 54. Then after dieing, I don't think I can hear the pump come on, and the pressure does not go up at all. I have a feeling tomorrow it will do the same thing, start up after sitting for awhile, then die after 5 minutes.
Does this sound like a fuel pump going bad? or does it sound like an electrical issue with the fuel pump?
View 1 Replies
I drive a 1999 Pontiac Grand Prix. Yesterday, I drove to the store about 5 minutes away. When I went back to my car 10 minutes later, it wouldn't start. Wouldn't turn over, no clicking, just silence. Finally had to leave it there. When I came back 1 1/2 hours later, it started fine. Same thing happened to me this morning. Drove it 5 minutes, now it won't start. What could it be?
View 3 Replies
My 1994 Aerostar, with 100,000 miles on it, started lurching at highway speeds. Weeks before this, the airbag light began blinking. The transmission man said it felt like it was shifting into overdrive, then out, then into overdrive, then out, etc.,etc. About this time, the cruise control quit being reliable. Dealership said codes didn't show a problem, "I must be mistaken". Then they said it sounded like a fuel filter.
View 6 Replies
1991 Chevy 1500 pickup truck. The heater is ALWAYS on, no matter what I do. I suspect that some sort of mechanical controller or vent shut off device/air mixer is malfunctioning because I don't think the heat is actually coming from the heater core, I think it's just engine heat.
I pulled the fuse on the heater which turned off the blower and controls, but the heat is still coming out the vents, especially at highway speeds. So this leads me to believe that exterior air is pulling engine heat into the cab.
I don't know how I would even begin to fix this. I need a starting point. Where would I look for the vent or flap or whatever that mixes the cool air with the hot air? The AC hasn't worked since I bought the truck about 18 months ago.
View 2 Replies
2006' screw, 5.4L, 116K miles ... The truck looses power at highway speeds to the point that I need to pull off of the road. When this happens the check engine light is on and the truck is still running but will not accelerate, is it possible the computer is going into limp mode and if so what would cause this?
View 1 Replies
I drive a 2004 chevy Tahoe and have had this problem for about 8 months. It started out very faint and occasional, but has now escalated to loud and consistent. So it ONLY happens when turning right. I've tried to replicate it when turning left and had no success. It happens when I am turning fairly hard at a decent speed. ex. Pulling into my driveway. I've already checked the wheel bearings and Ball joints.
Another thing is that the ABS light is on sometimes when i start the car and comes on every time i turn the steering wheel all the way to the right. It also has a problem where it will shake almost uncontrollably when driving at 65+MPH after hitting a bump or sometimes just randomly on a smooth surface. We just got new tires and balanced them. It did the same with the previous set we had. I know I'm asking for a lot, but where to start?
View 14 Replies
I have a 2001 Subaru Outback Limited with 135K miles on it. In the last year, I had two complete head jobs (the second because the new water pump failed while on the highway). In addition, I have had multiple water pumps, lots of thermostats and a new radiator installed. The last thermostat is an OEM. The car had been running fine for about a month and now overheats after about 30-40 minutes of combined, but mostly highway driving. At first, the gauge would rise to about 3/4 and then drop after about ten seconds, but now it goes to almost red and drops to 3/4. If I blast the heat, it will drop pretty fast. My mechanic told me that while diagnosing an earlier overheat issue (just before the good period), he noticed that the gauge would rise, but the computer temp would remain stable. He tried a new sensor, but said it made no difference, so he returned it. What is left to replace?
View 12 Replies
I was on highway doing 75 with cruise on. All of sudden the truck downshifts and continued to do this while on highway but not surface streets. Is it tran auto relay switch or solenoid (I have no leaking). 1996 s10 4.3l v6...
View 2 Replies
I have a 2001 chevy metro 4 cyl. with 13 inch wheels and automatic transmission. The engine rpm's are running high at highway speeds. Would a larger diameter wheel support this situation?
View 8 Replies
I was driving my 99 honda civic at a steady 65mph on the highway for about 10 minutes. I was not accelerating or anything, when it cut out totally as if I turned off the engine. When I would step on the gas (still moving), it would not even hit/sputter or anything. I pulled off to the side of the road and immediately tried to restart... nothing.
Two minutes later, I try to restart, and it started right up. Get going another 5 minutes, and it does the same thing. This time I only waited about 30 seconds, then it started up again, but it 'missed' a couple of times just before it started up. Then it was fine for the rest of the drive to work, and hasn't stalled since (one week).
However, the check engine light came on the next day after the stalling episode, and has also been on since. The code is P0420 (which says that the O2 sensor before and after the catalytic converter read similar, indicating a bad catalytic converter). I'm not sure if this is, however, a downstream effect/ symptom of a larger problem (that this is not the cause, but the effect of a larger problem?)
Here are some extra facts that may be relevant, or may be totally random:
I occasionally catch a whiff of egg like smell (smells like it's running rich, and maybe it is heating the catalytic converter)
It seems to be functioning fine (no loss of power)... the gas mileage even seems OK-I filled up with a new tank of gas the night before the drive (I've since filled up again)-There was an ignition recall, that I did NOT have done (I just found out about it -The car is pretty beat up: 170K miles-Gas gage quit working about a month ago... always reads full.
View 9 Replies
I am having overheating problems with my car, I had the car in the shop where they replaced the headgasket, got the head machined, got the radiator rodded out, checked the water pump, replaced the thermostat tried three different ones. The only way they could get it to run without overheating after doing all of this was to run it without a thermostat. I ran it that way for a couple of months, but it is getting colder where I live so I put a new thermostat back in it, now I am having the same problems, it runs somewhat OK while driving, it does not heat up right away maybe after 30 mins or so at city speeds, however at lower speeds it starts to heat up. If i put it in neutral and increase the RPM's the temp gauge will drop down.
After stopping I can feel the hose coming out of the thermostat housing to the radiator and the hose is cool, so for whatever reason the thermostat is not opening, I drilled an 1/8" hole in the thermostat to let any air through that may be in the system. When I refilled the system I opened the bleeder screw that is above the exhaust manifold until antifreeze came out of it then I closed it and filled the rest of the way.
View 14 Replies
My check engine light has come on, and I have white smoke coming from under my hood when I drive. I'm trying to diagnose this and fix it. My mechanic had my car for a whole day and told me he needed more time to find out what it is.
My car is a 2002 chevy impala, and the smoke only comes after about 10 minutes of driving, and only lasts for about five minutes. When I open my hood, it seems the smoke is coming from the right side of my engine, maybe underneath, but it's hard to tell, but when I look just below the right side of the engine it does look to be a little bit wet down there. The smoke has a kind of sweet smell. So far, the car is still running fine.
The smoke only comes the first time I drive my car for the day.
View 12 Replies
My sonata has started having issues on the highway at speeds ~65-75 mph. It will start vibrating, a little at first and gradually getting worse. As this happens my brake pedal seems to be more firm and touchy rather than soft and needing more pressure to stop. The vibration can be felt in the steering wheel and the floor as I drive. This has happened twice so far, with a gap of about a week in between incidents. What should I get checked out?
View 5 Replies
