I changed the radiator and thermostat, changed the coolant, and my fans work. however, whenever i take the car for a short drive, the temp goes up. I stop the car and shut it off, it steams near th coolant tank. it sounds like its almost boiling..
View 5 RepliesOk, I just bought myself some problems in the form of a '93 Celica GTS. (5S-FE)
Well, alright, that's a little dramatic. it just overheats. but here's my issue. it's got a new water pump, new radiator, and is still overheating. The guy I bought from says it's in the block, cuased by an attempt to plug a radiator leak with stop leak. He said it just had a minor leak in the radiator, so he put stop leak in it, and after that it started overheating. he's replaced the thermostat, water pump, and radiator since then.
My first question is, could he (and I) be overlooking something? could there be a clog somewhere easier to access? and then if there isn't, how should I go about cleaning out the block? are there areas I should check? anything I should do to try to unclog it? my current plan is to put cooling system flush in (he has some) and drive it home (about 55min. drive) with the flush in it, then empty it and hope for the best.
when it began overheating, and to be specific it is a 2003 Honda civic ex, automatic. I took it back to them after having to pay towing expenses. They said they didn't know it had issues (bull) they said it was due to a radiator, so they installed a new one. When I got it back it drove fine then it began exhibiting the same symptoms soon after. I decided since I loved the car I wouldn't even bother with the people I bought it from, big mistake and I should have just returned it...I didn't because I was sick of looking for a car and school was about to start. This began the routine of having to fill it with antifreeze every day before and after class, if I didn't it would most certainly overheat and then I'd have to blow hot air all day.
So I took it to another mechanic who figured it must be something wrong with the cooling system and said the fan was acting slow, so he replaced the fan-switch and thermostat and said that it wasn't the water pump. I was hoping this would do it, but it did not. He then tested the head-gasket twice and it came back negative. Then they tested the catalytic converter, came back negative. This mechanic, then proceeds to tell me the people who sold it to me may have put a sealant in which gummed up the engine and is clogging things so it can't function correctly, or put on the head-gasket wrong or any number of things to the engine. Although, wouldn't this still make the head-gasket test fail? He tells me I may need a new engine because to figure out if it truly is an engine problem that would cost as much as a new engine. I don't know what to do or where to go I am at a loss here. Spending my money just to have mechanics tell me there is some mysterious "undiagnosable" problem with my car is the most frustrating thing ever. No one can fix this car it seems.
Ok I have a 97 f150 4.6L. My radiator has been bad for a while. With brown rust color. I replaced my radiator, thermostat, new upper and lower hoses. Everything runs great but I have no heat. I flushed everything including the heater core. Core is not leaking into cab, and both heater hoses are cold. What should I do next FYI heat worked great until 5 days ago.
View 14 Repliesmy EX is a 2000 XLT 6.8 4WD I have 146,000 on it. Last week I replaced the expansion tank with a new one, went just fine no leaks, new prestone at 50/50, today she overheated to the red so I changed the thermostat, still overheating, no leaks fluid level good. What am I missing ????
View 14 Replies1995 Ford Van E150. So I've been trying to solve my overheating problem for months now. One morning I walked out of my house and all of my coolants was on the street. I could not completely detect the source of the leak after running more coolant through it. I also checked the dip stick and coolant on the ground for any sign of oil/coolant mixing. I started by replacing the thermostat.
I did a more thorough inspection and found a crack at the bottom of the radiator that I replaced less than two years ago. I replaced the radiator again and while I had the belt, intake and fan disassembled I switched out the water pump as well. The old water pump was gunked and the gasket was almost completely worn off. The van is still overheating and spitting out coolant at a much higher rate. I'm guessing because of the new water pump. A friend said it could be the intake manifold because of where the steam was coming from the motor.
I know many of the vendors for the Gencoupe will install lower temp radiator thermostats to keep the engine oil temps down.
What would the effects of this be on our turbo's? Grimmspeed makes a 140* thermo for the gc's and I believe it's 20* cooler than stock for them.
Would this to something we could do to protect from detonation and run the engine a little cooler during the hot summer months?
I have a question regarding a overheating problem I have with my 99GLS V6. I had the dealer do a timing belt, water pump, thermostat etc on my Passat about a year ago. I also have coolant leak in the metal pipes under my intake, which I haven't had a chance to tend to yet. I noticed recently that my car overheats and there was alot of pressure built up in the hoses. If I remember correctly, the thermostats are designed to fail in the open position. So I am wondering because of the leak, what's the chances that my thermostat could have failed in the closed position? I'm hoping its just air in the system and lack of coolant is causing this. It's been more than a year so I'll have to cough up the dough for this one.
View 10 RepliesI have a 2004 Honda Civic Lx and I was driving one day and I look down to see if I was speeding or not (easy to do) and I see that the thermostat is almost all the way to the red line. So I pull over to a store and check my fluids. The oil was low so I put two quarts in. There are no signs of leaks anywhere. I also topped off the coolant. Ever sense the care has been fine so could of it been the low fluids?
View 5 RepliesI got an 88 celica convertible from my neighbor. This is a fixer upper. It needs a battery and an alternator. But i jumped it and after idling for 10 minutes, the temperature Gauge was almost in the red. Yes the radiator has water in it. Is it the thermostat? Or the head gasket?
View 2 RepliesI purchased my 1993 Toyota from someone who modded a bunch of stuff in the engine, including putting in a header, taking out the Catalytic convertor, removing the A/C compressor and moving/rewelding different pipes (including the cooling system pipes).
Anyway, I've noticed that it's heater has never worked, and I just figured I needed to replace the thermostat. In the stock engine, you need to drain the coolant system, and then remove the bottom radiator hose. I did that, and discovered that when he welded the new coolant pipes on, he failed to put in mounts for a thermostat, and there was no thermostat there. Is this fixable at all, or am I stuck without a thermostat (and heating in the winter?)
My engine started overheating, and because I was stuck on a bridge during rush hour (George Washington Bridge in NYC), I couldn't get stop the car. I drove it for approximately 30 min (slow crawl), and this happened: [URL] .....
Yes, I know how stupid it is, but there was not even a shoulder to pull over to the side. The only good thing is that this happened pretty much soon as Igot off the bridge, and not on the bridge.
Hose by the radiator cap (is that the overflow hose?) popped out and spewed steam for good 5 minutes. The car did not start at this point. I left the car by the gas station after the bridge, and came back later on in the night. It started and I was able to drive it home (about 10 min away) at crawl speed without it reaching the red zone.
Today, I just did the oil change, topped off on the coolant, and also replaced the thermostat. But the engine still overheats (to the red). The upper radiator hose is burning hot and the bottom radiator hose is not. Also, the fan is working, but it blows out pretty hot air.
2.2 liter celica would improper placement of thermostat jiggle valve cause water to boil in upper radiator hose and overheat engine and spill water from overflow.
View 10 RepliesSo my 2005 elantra gls has been having overheating problems. A few weeks ago, it overheated one day driving around town for about 30 minutes. I kicked on the heater and made it home. I went out the next day and didn't see any problems. Everything went fine for two weeks, then yesterday the problem happened again. I read about the thermostat often failing, so I did some research on that and replaced it today.
For replacing the thermostat, I followed the lower hose and found the housing, removed it and took out the old thermostat. Removed the old gasket, cleaned around the connection, dried it off. Then I put the new thermostat in , put some gasket sealer down and putthe new gasket on. Finally, put some more sealer on the outside of the gasket and put the housing back on.
After replacing it and immediately turning on the car, I got a High Oil Temp code. I cleared the code and let the car idle for while. After about 15 minutes I went for a drive around the neighborhood and then took it out on the highway for about 10 minutes. It started overheating by the time I got home. I turned it off and when starting it again I get the High Oil Temp code.
Is it possible that I didn't do something correctly with the thermostat. If not, what else could I look for and could I have bumped/damaged the oil temp sensor?
problem is the my 1998 Legacy (142K) overheated this past weekend. It shut off and I had it towed to a "new" mechanic around the corner from my house. He diagnosed the problem as being a faulty thermostat. He replaced the thermostat and returned the vehicle to me. Two days later my wife was driving home and the car had a major overheating incident with resulting serious mechanical failure. I did a little research and within about five minutes found that this problem is quite common for this car and is more commonly related to a head gasket issue. My question is should this mechanic be held responsible in any way for the misdiagnosed problem? If so, what would be the best course of action? The car was otherwise running fine and in fact I recently had the transmission rebuilt.
View 3 RepliesBought this truck at auction a few days ago. Started drive home and noticed temp gauge almost pegged full hot. Stopped and left it and pickup up later that day with trailer. Got home and started and ran it. Will not overheat at idle. Gauge fluctuates between full cold and 1/2 at idle. Rev up and temp drops to full cold. Drive around town under 35 and it stays between 1/2 and 3/4. Get on the highway and Pegs full hot. Replace thermostat and flushed system. Lots of rusty water and chunks of rust/mud poured out.
Upper rad hose is firm and hot. Lower rad hose is warm soft. Bypassed heater core and still over heats. I can run water hose from top hole on radiator and water crosses threw radiator and pours out the bottom so I don't think it's clogged. It's not the head gasket, I have no smoke, no milky oil and no oil in coolant. Fan clutch seems fine, I can spin it with the engine off and feel resistance. Truck hasnt boiled over while running hot so the gauge may be wrong. If it means anything the truck runs very rough and pulled up a misfire on cylinder #1 and had a iac code.
I had a leak in my water pump so we had it replaced and a new thermostat. Now it is overheating in just about 2 minutes and my heater is now not working. I was told that it is most likely an air pocket in the coolant. I have let the car heat up, not to the point of hot but over half way and shut it off, taken the cap of let it sit for a while and then trying it again. No luck so far. Is there another way to get it out of there? and would the cap have anything to do with it? it has been hard to take off in the past and now its coming off easy. It is the plastic kind. I am at the end of my rope here . the car runs like a dream, its just this one thing.
View 12 RepliesMy son has a 2002 Jetta, we just changed the water pump and the thermostat. The car will sit at idle and the temperature will stay around 190. When you drive down the road the temerature will rise and when you let off teh gas the temperature goes back down. What this could be, I have tried everything I can think of to fix this car.
View 13 RepliesI did an engine swap for a junkyard motor my 4.0 ohv had a very bad rod bearing so I got one from the junkyard with 117,000,or so they say.Anyhow, after its all said and done it runs perfect except the temperature gauge seems to not get as high up on the gauge as before after sufficient driving(it used to run about middle of the gauge) it drops low at idle then goes up and stays up then goes down.it still has good heat, doesn't seem as good as before tho.I changed the thermostat also.
View 8 RepliesChanged the plugs, wires, cap and rotor. I can't seem to pinpoint what causes the failure to start to occur. The starter engages and the motor turns. Letting it sit for an hour seems to solve the problem.
I have not replaced the distributor yet.
I have a problem with my Toyota Camry 2002 4 cyl. 2.4L, I changed my Motor cooling fan but my car keeps overheating, I changed the overflow tank top, but still its overheating and the car turns off by itself sometimes, when its cold (after i turn it on) it starts bucking and also if its stop (example, if i park somewhere), and at last, the temp isn't showing correctly on my dashboard.
View 2 Replies