Celica :: 1992 Toyota - Engine Knock Quite Apparent At Idle / Low Rpm
May 9, 2011
Alright so I got a 92 toyota Celica 2.2 5SFE recently and guy before did a head gasket.. well i started to work on the car. fix things here and there. well one issue I cam across was low compression.. 170 170 30 90.. so i was like ok the guy didnt do it right.. took it apart. found out valves were stuck open. So i ordered a remmaned cylinder head to put in and new head gasket set etc.. replaced all gaskets that came with it..
Also put in remanned fuel injectors due to one leaking so i just replaced em all. New plugs, wires, cap, rotor, timing belt, followed the oem manual word for word to install and remove and timing is right. But I got it all back together and ran great. until my tps went out(replacing that soon). Compression is now 180 across the board.
Now I got a knocking issue, Its quite apparent at idle/ low rpm.. solid sound, goes away at higher rpms, gets plenty of oil to cylinder head, started bout 150 miles after finishing. Im not sure where to start.
View 3 Replies
Advertisement
It's a 1992 Celica, GTS 2.2L for reference.
After driving down the highway I noticed my temp fluctuated from half way to full and bounced around until I arrived at the closest Canadian Tire/Station. I looked under the hood and noticed the stain on the coolant container wasn't the actual level of coolant. I then topped off the coolant and parked the car for about a week. When I tried to start her up, I was faced with a weak and poor idle. Almost as if the car is struggling to run. I have had times in the recent years in the summer months were I felt I had to pump the pedal on really hot days to kickstart her so she would run. Was this a warning sign? Other than this problem I face, the car runs smooth. I did a good tune up 2 years back, replacing the ignition coil, plugs, etc..
The idle goes from 0 - 500RPM in neutral and when I apply gas it struggles to gain power. The car is parked, I don't dare to take her around the block. It stutters and seems like she is struggling to get fuel. I say that because, when the key is turned to the on position I do not hear the fuel pump underneath the back seat activate. I did try jumping the terminals, something like B+ and FP.... The pump turned on and I heard fuel but when I started the car, I still had the same problem. I would need to pump gas or she would stall out. I do not know where the fuel line is to try and check the pressure or even where the relay is located.
Could it be the Fuel Pump?
Could it be the Fuel Pump Relay?
Something Else?
My guess is the Fuel Pump, but if you could take a few mins and replay that would be great. I have had my Celica for about 7 years and I would like to keep her going!
View 4 Replies
I just bought a 92 Toyota Celica for something to play around with. It's got just over 200,000 miles and everything seems to run alright except there is a really rough vibration at idle. The vibration is so bad that it's almost visible. You can still feel the vibration in drive but it isn't nearly as bad.
Any clue at what could be causing the vibration? I'll try to get a sound clip or video uploaded ....
View 5 Replies
2002, Has about 130k miles
1) Engine rattles at 3500rpm. Only at 3500rpm. 3000 is fine, 4000 is fine.
2) Just had my brakes replaced. They knock when I brake moderately, took it to the mechanic, who replaced them. They knock less now, but still knock. The knocking sound is kind of a pop that happens at 1 second intervals.
View 8 Replies
I recently bought a 92 Celica gt (5s-fe). The engine feels like its misfiring and wont idle on its own.
I've done all the normal maintenance to it and the spark plugs all show normal signs of wear. I haven't verified fuel and spark yet. Check out the video below. The piece of cardboard is to keep the throttle partially open. Also, the exhaust is broken off at the flex pipe so excuse the awesome sound ...
[URL] ....
View 5 Replies
My 1992 Toyota, Celica had developed a really weird idle surge. The idle surges between 500 to 750 rpm. The surge goes away with the AC on and it idles steady at 900 Rpm. It also has a slight off idle bog that may just be another symptom of the weird idle.
I did the diagnostic test today and it doesn't flash any codes. I pulled the EGR valve off and cleaned the gunk out of it and it didn't make any difference. I tried to check the timing and it idles so bad the timing bounces 7-10 degrees with the surge. When I did the jumper to check the timing it would kill the engine. The plugs and wires are new with in a couple thousand miles. It runs fine above idle and pulls to redline easily in the lower gears.
Yesterday when I was messing with it I had the car running with the air boot from the air cleaner to throttle body off. I sprayed carb cleaner into throttle body and it seems to clear up a little bit. Then it went back to surging again.
I tried to pull the TPS off yesterday and of course the bottom screw stripped out. Now I will have to pull the throttle body off to get the screw out. I wish it would throw a code so I could have it give me a clue.
View 8 Replies
I just bought this little car. It ticks at an idle and it burns 1/4 qt of oil a month. It doesn't stop ticking when I add oil so Im at a loss.. It isn't a loud tick either. It has 200,000 miles on it but it is in great condition besides this.
View 13 Replies
I have a 1992 toyota celica st204 i got my dignosis and it come up with 12rpm signal cranking just wondering what it is and if it will cause my car to lose a bit of power .
View 1 Replies
I have a 92 Toyota Celica GT five speed that won't going to gear occasionally. I can drive several months at a time without having a problem and then all of a sudden when I start the car to put it in gear and I have to literally force it into gear or turn off the car and put it into gear. I can go 5,6,7 months at a time without having a problem. Then all of a sudden it won't work. I would say within the last year I have had the problem I'm maybe three times. The last being yesterday since about September. I have had the car for 10 years and have replaced the clutch maybe three years ago. I have been driven a manual shift car since I was 16. Last year around March I replaced the slave cylinder and the problem seem to go away. Do I really need another clutch?
View 5 Replies
I got a 87 Toyota Celica 1600 GT, with a TVIS 4A-GE engine in.
My problem: when i just start the engine cold, it revs to 2500 RPM, and stays there for 1-2 minuttes and then falling to about 1500 RPM, and when the engine is completely warm my idle is about 1000 RPM.
first i think that 2500 RPM cold is a bit to much, and i dont know what to do with it. but my biggest problem is when the engine is fully warmed up, and i rev it to lets say 3000 RPM and then lets the gas of, the engine falls to about 500 RPM sometimes it stalls but if it not stalls then it would slowly gain some RPM and then it goes up to 1000 RPM again.
How can i prevent the engine falling that much when i let the gas off? it's quite annoying when i drive the car and comes to a stop it sometimes stall.
View 2 Replies
I've had this noise on my 92 GT since I bought the car and it hasn't got any worse but I still am wondering what it is in case it's something serious. I hear a rattle/clatter coming from the engine or thereabouts, and it only happens under load (doesn't have to be heavy load, but I can't hear it in neutral or when the clutch is disengaged). It only happens above around 3000 rpm and the frequency of the rattle corresponds to the engine rpm. It's difficult to pinpoint the location of it because it only happens under load. Anyway, I made a short video of it and uploaded it to YouTube....
View 8 Replies
I am repairing a 1992 Celica GT w/2.2 litre I4. Just replaced the TPS. Now, it will only idle. Any caressing of the accelerator, and the engine dies. Will idle smooth as glass for abt 5-10 minutes, then begin idling rough, and then die. Will not allow me to restart immediately after it dies. Must wait 10-15 minutes before restarting. When the vehicle is placed in gear, it will continue to run, but the moment the accel. is pressed, the engine dies.
I think part of it may be vacuum-related.
View 4 Replies
I run my 92 celica for a good 30 miles and check engine light comes on but after driving another 20-25 miles it turns off. I red the code it was the Egr (code 71) I took off egr valve and cleaned it out idk if its bad, how to test the valve?
View 1 Replies
I have a gorgeous, mint 4x4 1992 Toyota pickup...that runs terribly. Sometimes, it won't start. When it does start, it often idles very, very low. (Idler tension cable was adjusted up but it didn't work.) When I drive it, the idle goes up and down between very low and 4000 RPM. Sometimes, it stalls out all together, regardless of what I do to the clutch, brake, or acceleration. In an engine diagnosis, Knock Sensor came up, but there's a new one, and the cable harness is fully gone through. It's got a new engine with 67,000 miles on it, a new fuel pump, and just about every part has been replaced. It's been to about 10 mechanics, all of whom can't figure it out.
View 11 Replies
At idle (like at a stop sign or sitting in the drive way) my '92 Toyota revs up and dies down (kind of a "brrrrvvvvvv-buh... brrrrvvvvvvvv-buh") We have been fixing it up and got ahold of another Toyota that has a decent motor but the body, frame, and everything else is shot. We are pulling a starter out of it and was wondering if the part that causes the gallop could be replaced too.
View 4 Replies
I just recently purchased a 1996 celica GT Hatchback. It had 263K on 235K the timing belt was changed, oil and filter, tire rotation. When I bought the car on the 13 of August it drove and ran well. Drove it home over 45 miles with no issues. Only issue I noticed was that third gear grinded a bit but it's to be expected. Today after it had sat for all that time with the lights on the battery was dead. Jumped the car. cleaned and protected the contacts on the batt. and hooked it all back up. Let it charge for an hour and then drove it to work. On my way to work the engine oil light came on and the car died on my. It has oil and there are no apparent oil leaks. The car is turning over but not starting.
View 8 Replies
My 1980 Toyota Celica (5 speed, R20) is backfiring a little when idling and also more if I am trying to slow down by using 3rd or 2nd gear - engine braking. So far I changed dist. cap & rotor, wires, spark plugs, muffler, all fluids... and it's still happening.
View 2 Replies
Since having my engine replaced with a newer used engine block my idle speed when I first start it up or when it is cold is around 2000rpm which lasts for about 2-3 minutes until it begins to fall to the normal range of 1200-1400 and finally to 850 or 900rpm when warm. how can I fix this or is it okay to idle at 2000rpm for a couple of minutes? is it hurting anything?
View 3 Replies
The car: 1994 toyota celica GT 2.2L automatic
Here's the problem: car starts fine when cold. When fully warmed up, if i stop to go to the store or something, and then start it after like 20 - 30 minutes it will start and the idle will be fluctuating between 800 and 400 for a few minutes and then even out. sometimes it will actually start up and die immediately, in which case i can save it by giving it gas for a few seconds and then it's fine.
What I've done so far: plugs (NGK), wires, cap, rotor, fuel filter (toyota), (checked air filter. still clean), tried cleaning the throttle body and IAC with some deep creep spray while on the car (not much effect).
View 14 Replies
My 2001 Toyota Celica GT was put through a smog test and it was running rich on the idle only. It has been tagged a gross polluter and so i finally got a code reader to try to diagnose why. When i plugged in the code reader it kept stating no codes. It does not have a check engine light on and has not had a tune up for a while now. I am in real need of my car now more than ever.
View 2 Replies
I have a 2001 Toyota celica GT auto. It has 120k miles. I seem to have an issue that really is not causing a problem except for annoyance. After coming to a stop the car seems to exhibit the signs of stalling (car idles rough, shakes a bit) however the car never stalls. Once I start driving all is well. Now I took it to the dealer and they replaced the Idle Air Control Valve which is under the throttle body. They said it was getting stuck and due to the higher mileage possible. It was replaced and the problem is still there. The funny thing is even though the car exhibits these stalling symptoms the idle does not drop below 500 rpm (both dealer and I have verified this).
View 3 Replies
