Caravan/Voyager :: Brake Shudder On A Downhill Slope
Jul 4, 2013
2008 Dodge Grand Caravan SXT 4.0L 47K miles. I am having a bad issue with the brakes.
I have had to replace the front brake pads and rotors 3 times and going on the 4th time IN LESS THAN 47K MILES. The brakes seem to work fine in city driving where the streets are flat. The problem is when driving on any kind of a downhill grade. If you try to brake on a downhill slope the brakes shudder so bad that you cannot only feel the steering wheel shake, you can SEE it shake.
The Dealerships say the problem is warped rotors and everything is fine after installing a new set or turning the old set. After the 2nd set of "OEM" rotors supplied by the dealerships (two different Dealerships to be exact), I got fed up and installed top of the line NAPA Ceramic pads and Rotors, which do the exact same thing after less than a year/7k miles. This van is not a commercial vehicle, and is not overloaded or used for towing.
View 5 Replies
Advertisement
I am experiencing a very frustrating shift anomaly. 2003 T and C . Under certain throttle conditions ( usually light ) from a dead start I am feeling a bump/violent shudder between the 1-2 transmission shift. If I let off the gas, I can get the shudder to quit and then by continuing to accelerate , successfully complete the 1-2 shift.
Does not happen all the time and never under straight ahead med-hard acceleration. By nature , happens most of the time under light acceleration when turning a corner from a dead stop. Sort of feels like a loss of traction or something funky happening with the torque convertor. Have serviced the trans with new fluid and filter, new TPS, new plugs, wires, and coil pack.
View 1 Replies
So here I am with my 1996 Dodge grand caravan that I purchased new in 1995 for a whopping 30k. Yeah hind site is 20/20 skip forward to mile 102k transmission fails completely. Had to have it towed in to shop, rebuilt tranny put in... skip ahead another 4 years to mile 173k and transmission fails again. Again on a tow truck to the shop and ANOTHER tranny rebuild. So now I am at mile 182k and transmission is making a horrible shudder and I have moved across the country away from original shop that did last trans repair (who says they only warranty if I come back to them) and I am possibly looking at another repair or replacement. What is the deal with these vans?
View 4 Replies
I have a 96 voyager, it has been a great car for the last 10 years I've had it. My brake pedal goes down to the floor, it gives brake but I think barely and my brake light comes on. I have Bled it twice and changed the master cylinder , neither worked, I'm perplexed, my mechanic thinks it is the abs.
View 3 Replies
I'm working on a 2008 Grand Caravan SE 3.3L Brake warning light (!) on dash is on. Datastream on my OTC Genisys shows that the Brake fluid level switch is 'ON'.
The van does not have pad wear indicators; fluid is full; there are no leaks in the system; no brake pull, uneven braking or other performance issues.
Scantool says Park Brake is off and I disconnected it to be sure.
When checking connector at switch on the master, one wire has continuity to ground and the other has about 12.5V on the DMM but won't light my test light.
View 4 Replies
My old 1997 Dodge Caravan (150k miles) has weak brakes. During normal driving, it needs more pressure on the pedal to brake normally, than any other car that I have driven. This would be ok as I can push hard on the pedal... But the problem is that, past some point, I get no additional braking power no matter how hard I push.
So in case of an emergency, I cannot come anywhere close to lock the wheels (and this car does not have ABS). So basically, the braking power is proportional to how hard I push, up to a point where the braking power remains the same no matter how hard I push. At that point the pedal is maybe 1/3 down, still very far from the floor.
I have just replaced the front pads and rotor with no improvement. And when the engine is not running, the pedal gets really hard after I depress the brakes 3 times, indicating that the booster is doing something. The car will stay in the driveway for now as this is a dangerous situation.
View 6 Replies
Just have a quick question. I am replacing some rusted brake lines near the gas tank. I already have the rusted ones cut out. I want to know if this junction box is really needed. If not it would sure take out alot of bending the lines. It looks like the line only come down the frame and bolt into the block and then straight out to the rear wheels.
[IMG][/IMG]...
View 3 Replies
My right front brake caliper is frozen and I cannot turn the tire. This happened about a month ago and I went to Autozone and they gave me a new caliper, rotor and brakes, under warranty, and now the caliper is frozen again and I cannot turn the tire when jacked up. It seems to release after a period of time. I am not sure if it has a proportioning valve for the front brakes, but the driver side wheel turns freely and is not stuck.
View 2 Replies
Wife telling the brakes went out but fluid is leaking under center of vehicle when brake is pressed. Is this just a rear brake line issue?
View 2 Replies
98 dodge caravan 3.3L v6 ..... All lights work including driver's side tail lights. only problem is that when pressing brake pedal, the driver's side brake light does not light up. i changed the bulb and checked the brake light fuse under the hood, but it was fine (as i guessed since the passenger side and middle brake lights work). I took the assembly off and reseated the connector to the tail light assembly, but same issue.
View 2 Replies
How to adjust parking brake pedal. I am sure it should be common problem at some time for everyone. My car has 93k miles and now parking brake too loose and not holding car anymore, when car on slope.
View 2 Replies
We just purchased a 2012 Grand Caravan and was wondering where to get a key and program it. I know the key will be an arm and a leg if i get it from the dealer. Is there a tutorial that tells how to program it as well?
View 3 Replies
2006 Caravan. Heat comes and goes every minute or so. Also noticed the temp gauge goes from normal operating range to cold and back again frequently. Hasn't overheated. Does that sound like a thermostat problem?
View 2 Replies
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
View 1 Replies
What am i missing i have a terrible clunk in the front end when i hit bumps. I thought it was the struts and mounting plates so they are new . no change Stabilizer links were tight but i replaced them as well. Everything else seems tight but the noise has not changed with any of the above mentioned repairs.
View 13 Replies
I'm having trouble with my 96' 3.0L, its kind of crazy its intermittent and while driving the engines surges one or twice and then dies... when I try to crank it up again cranks but don't starts if I try again it wont even crank ( no starter winding up ) what I noticed is that is I'm driving when it dies my check engine light disappears for a while and if I connect my OBD 2 reader does not link up with the ECU if I wait a while and I crank it up again its starts and the while cranking up I can hear a bang noise from the engine compartment drives side and then after a couple of minutes dies again...
View 4 Replies
I have a 2006 Grand Caravan 3.8 that just stalled at a set of lights yesterday and have had it towed back to the shop here. I turns over and starts briefly then will die and then just turn over strongly. I cleaned the throttle body and IAC but this did not work. I connected fuel pressure tester and have no pressure when turn key on or turn it over.
The fuse and relay check out ok, so I'm thinking bad or clogged fuel pump.
I have a 2004 Caravan out back that I have used for other small parts to interchange before and was wondering whether or not the fuel pumps between these two are compatible. Be a lot of work to pull the one off the one in the yard, only to find out its not going to fit.
View 3 Replies
142k, having some problems lately, the van won't accelerate now and again, moreso when the engine isn't up to temp, but lately it's gotten more and more prevalent. I have done some recent and needed maintenance in hopes of fixing the issue, but to no avail so far. I've replaced the plugs and wires, air and fuel filters, and both upper and lower O2 sensors (first replaced the upper with a Bosch, almost immediately had problems with P0134 code, so instead went with a Denso, hasn't come back yet). I checked fuel pressure, 60 psi sitting in the shop, the cat doesn't seem to be clogged, and it idles fine all day long.
Problem resembles running out of fuel, or more maybe like I'm letting off the gas, but my cheap scanner says the TPS is working fine, and I was watching the TPS percentage as I was driving it was reading normally. As I'm accelerating slowly from a stop, it'll start to cut out around 30 mph, but speed doesn't seem to matter, if I accelerate sharply it just bogs and slows down, if it does shift up a gear, the rpms will jump to about 5k, then slowly decrease even if I've got my foot on the floor. I keep coming back to the fuel pump, but I don't have a long enough hose to have it connected while test driving. Considering removing the hood so I can prop the gauge up so I can see it while driving. I am getting a P0132 code now, but I'm more concerned with the accelerating issue.
View 14 Replies
Intermittently the ABS Light is coming on. 84,000 miles.
Brakes have been changed once, 10,000 miles ago.
Minor clunk sound when light is on.
Light goes off after van has set, brakes work fine at that point.
View 3 Replies
I've been fighting with these vehicle for months, and I've only been able to narrow down the list of possible issues. Tried replacing the ignition switch, battery terminals and cables, starter, and even a PCM since according to the dealership it was bad. I've checked all the fuses and relays, and they're all ok.
I'm getting fuel and spark, but no crank from the starter. The voltage going to the hot post on the starter is 12.7, but the voltage from the igniton wire is only reading around .5-.6, fluctuating a bit. Before I spend the money on taking it to a mechanic I wanted to know what your opinions were on what the next step is. I know a bit about electrical systems in cars but I'm no expert.
View 3 Replies
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 Replies
