Caravan/Voyager :: 2000 - Overheating After Driving On The Interstate For Half Hour Or So
Jan 26, 2012
My GC is overheating. Started as occasionally but now increasing in frequency. I find it will being to overheat after driving on the interstate for half hour or so but I can "calm" it back down but turning on the heat. I've replaced the following:
1. coolant (no drips or leaks nor am I losing coolant over time)
2. thermostat (twice)
3. temperature sensor
4. serpentine belt and tensioner
5. radiator (last summer)
6. water pump (last winter)
I notice the fans run more often than they should. For example, after a 10 minute ride to work in the morning,. I notice the fans are running as I pull into my parking space.
View 14 Replies
Advertisement
My wife has a 2000 t&c with 150k on it its a fwd with 3.8 and about a month ago while driving we noticed the rpms will jump up 400 and go back, with cruise control on or off being held at a consistent speed. and about for days ago it started shifting late. Still has all gears fluid looks o.k. and is full no check engine light .
I am hearing transmission solenoid, tps sensor, input sensor, output sensor, tcm, iac, map, or egr are all possibilities or a rebuild . Or simple as a flush.. tonight i went out n started it it idles around 800 tried to hold it at 1200 and it would for a second and drop back to 800 with accelerator being slightly held. Not sure if related. Just observed it..
View 2 Replies
Just replaced the starter and battery on my old but loved 4Runner. I drove it for an hour and a half last week and couldn't restart it. Just nothing - one click I think. A friend tapped on the starter and it started...but I'm not sure whether the car just cooled down at that point. Took it to the garage and they said they couldn't find anything wrong (no surprise, right?) Now I'm afraid to take longer trips.
View 2 Replies
I have a 2003 rav4 with about 100000 miles on it. Over the last 4 months I have noticed that, whenever I drive half hour or longer on the highway the car starts to smell like burning rubber or burning antifreeze or something like that. I live close to work, play, and groceries, so I don't drive it that long very often. I have not noticed decreased levels of any of my fluids. No change in performance either. I've had the oil changed regularly and no problems there. I am about to drive it a thousand plus miles and would love to get this figured out before I go.
View 7 Replies
I noticed through careful investigation that my 03 GTI 1.8T (180,000 KM's or 111,850 miles) will grind 3rd when in these conditions:
1. When the car has been driving for more then half an hour and everything is hot
2. When the car is over 2800 RPM's while hot (ie. getting on a highway)
Now I know lot's of people blame syncro's and yes I could see that my car has had 8 previous owners so I can't say they all shifted perfect. But what I do know is that when I downshift from either 4th or Neutral it will never grind even when I don't Rev Match or "Blip" the throttle. So it can't be syncro's in my opinion.
So what I've done to the car to rule out some problems were:
- Change the gear oil from what ever it was before to Royal Purple 75W-90 (NO luck.)
- Then I added a short shifter and adjusted my cables properly (still No luck)
- Finally I noticed my shifter was sloppy and one of my bushings were torn so I bought 42 DD's metal bushings and the shifter did stiffen up a lot, however!!! (No luck)
I know it's not my driving technique because I watch my foot depress the clutch fully and then I gently push it into third. I also know I'm shifting correctly because I can double clutch and normally shift through every other gear properly without any grinds or clunks. Just the devilish 3rd gear.
I would like to hear the solution. I'm going to change the oil one more time to Redline MT-90 and see how that goes, but if that doesn't work I might just tear apart or get a new tranny.
View 3 Replies
97 2.4 caravan dies while driving. Its been going on for awhile, coded at o'riellys and autozone several times. It started with having the camshaft and crankshaft replaced. Problem solved for a few days but it always returned.It would restart a few minutes later then it got worse. I called it the 30 mile van 'cause that's all it would go before dying or not restarting immediately.
Go to the grocery store, have to wait another 30 minutes to go home. Then it started only going a few blocks before shutting down while driving. I replaced the o2 sensor, the shutoff and fuel pump relays and finally took it to a shop that engine coded it. On their advice, they said the codes were all over, jumping everywhere, we replaced the ECM. It went 5 hours driving great then died and immediately restarted. Again no dash codes.
View 1 Replies
I have a 2003 Dodge Grand Caravan and while I was driving it stopped on me. It will turn on but once you put it in gear it will turn off and wont turn back on. I have replaced the fuel filter and fuel pump.
View 3 Replies
96 plymouth voyger se 3.3 6cly motor cut off while driving down highway or when stopped no check engine light...
View 1 Replies
I had to replace my swaybar links on my T&C due to it not passing state safety inspection. There was also some random noise that occasionally occurred on bumps. The tech said the "book" said to replace the strut and strut mounts but he could not see anything wrong. After replacing the swaybar links, there is now clunking while driving. I thought it was a lack of grease in the links but I greased them and while it got a little better...it still happens.
View 5 Replies
I just replaced the transmission in my 2000 3.3L Grand Voyager and now it won't start. It started fine when I drove it into the shop. The battery is good, the cables are ok. The starter worked good up to this point. I checked all the connections to make sure they are tight. I replaced the transmission because reverse went out.
When I turn on the key, the shift letters (PND32) appear on the instrument panel, but the little circle that shows what gear it is in does not appear. When you turn the key to the run position, the circle should be around the P to show it is in park.
When I turn the key to start, nothing happens. No clicks or anything. The next thing I am going to do is see if there is power to the starter when the key is in the start position. Where to start looking?
View 14 Replies
I am about 600 miles from home and when I was driving on the intertsate the battery light came on. I am in northern Maine where there are long stretches of nothing. I checked to make sure the belt was on and it runs fine. When I got to civilization I shut it off and it started and the light went out. Now I don't know if I should trust it or try and get to a dealer 70 miles away?
View 2 Replies
My wife has been driving our 98 Dodge Grand Caravan the last couple of days and while she is driving the Tachometer and Speedometer will drop to 0. This does not affect the performance of the engine or anything else. Runs and drives "perfect" (or at least for its age and mileage). The dash seems to "reset" when she parks and turns off the ignition then restarts it.
View 2 Replies
My 2000 dodge caravan with the 3.3 is shuddering while in gear and not moving especially in reverse . As soon as you start going it stops . No slipping whatsoever. The van only has 130'000 miles on it .
View 2 Replies
Issue on grand caravan 1996 happen, while driving all one time I hearing a clicking noise inside dashboard and abs+airbag and weather control, they stopped to work all in one shot .
View 1 Replies
2007 Grand Caravan SXT, 86K Miles
Factory Radio Clock, AM/FM, CD and Tape Player.
Radio and Clock looses power and completely shuts off and will not turn back on while driving. Miles driven does not seem to be consistent.
All other Electrical seems to work fine, overhead console, Wipers, Blower, Turn Signals, Head Lights, Instrument Panel all seems fine.
When car is shut off, Blower continues to run for a few seconds and then stops.
When car is restarted Radio/Clock magically comes back, clock is reset to 12:00 and radio is on AM.
Get some funny flashing of Idiot lights on cluster that to my recolection is not normal behavior. Once while my wife was driving it the Vehicle Theft Alarm Light came on when she started it up and it stayed on until she stopped and then started it back up when she left the store she was at. That has only happened once.
I checked the Battery Voltage while running and stopped and all seems normal. The Battery was new this December. I also checked fuses and there are none that are blown.
View 1 Replies
My van just started to have this issue today with jerking real hard like its dropping a couple of gears while going between 50-60mph. It is a 2000 with the flex fuel 3.3L 4 speed auto.When this happens the spedo will go from 55mph to 40 instantly while keeping a steady speed and it feels like the tranny is going to rip right out. This will happen every 5 to 10 min but go back to normal driving after 3 sec and has not popped any codes. It runs like a top and all fluids are at the correct levels. I have to commute 50 miles a day to work so i really need to figure this out!!!
View 1 Replies
Drivers side not bowing hot air? We changed the blower motor and the resister on the passenger side. We hadn't tried to use the heat until last night when we needed the defrost and that's when we realized only heat on passenger side.
View 1 Replies
Dodge Grand Caravan 2000 3.0L
First, sometimes the engine began shuts off. When the drive up to the traffic lights. When sharply throw gas pedal. When the engine speed is less than 2000. If you release the gas pedal, you will see that the tachometer needle drops below 500 rpm and the engine stalls. This happened happened two or three days all right. And sometimes a day, 3-4 times shuts off. Then ringing under the hood.
Was the flywheel. I remove the transmission and replace the flywheel. More repair parking brake pedal. So it turns analyzed under the panel. I have a new problem. After repair. I driving my Dodge week. And once. After an overnight stay the machine, on morning the engine not start. I checked the spark. The spark is. I removed the fuel hose. and there is no pressure. Just a little bit of fuel.
I decided that this is the fuel pump. I took off his tank, bought a new fuel pump. The pump has not changed. Today I decided to apply voltage to the old pump, it still stands in the tank. It works. Buzzing. Then I decided to check the voltage on the connector. I turned on the ignition. The instrument appears briefly on 12 volts. They are only momentary. Now I think there should always be 12 volts? Fuel tank removed. All hoses are disconnected. Not really the problem in the fuel pump? How to troubleshoot? Where can I get the wiring diagram?
View 2 Replies
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
View 12 Replies
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
View 4 Replies
So my radiator fans were staying on until my battery died and my car was completely cooled down and off. I was told it was a sticking relay so I replaced it and the fans still won't come on. I unplugged the coolant temp sensor and the fans came on so I know its not the motors or anything.
View 5 Replies
