Caravan/Voyager :: 1999 Engine Won't Crank Or Turn Over Just Some Clicking Near Relay Box
Jun 27, 2004
Intermittent problem, occurred 4 times during past 4 weeks, always during wet/rainy/damp weather. Three times when car was sitting overnight, once at work in parking lot after a 12 hour work shift. Each time, the engine started 5 or 6 times then died like someone turned the key off two seconds after the engine started. Then the engine would not crank or turn over, just some clicking near the relay box under the hood. Lights, power windows, etc. all work fine. Battery voltage OK. Jump starting or battery charger makes no difference. Note: With key in "run" position, no display to odometer though all idiot lights light up like normal.
1st time, after about 15-20 minutes, car started. 2nd time, towed to my mechanic (who thought security system lock out) then a second tow to dealer. Dealer found power into power distribution center but none out. Replaced PDC. Car worked fine for 1 week. Same problem twice since repair. First post repair failure I had van re-towed to dealer. Of course, it started for them. Left overnight 2 more nights. Started for them every time. They say it is a "problem with computers" but they don't know exactly what. They also say the Alarm set Dash light is coming on with the rest of the dash lights and that is a no-no. 2nd post repair failure happened this morning. Tried locking door to reset alarm. No change. Locked doors, opened rear hatch. Lights flashed but horn did not sound. When car is working and I do that (open hatch with other doors locked), in addition to lights flashing, horn beeps! I also disconnected the positive battery terminal, waited 10 minutes, reconnected and attempted restart. No change. Car still won't start and odometer display does not work.
Van has 110,000 miles. Otherwise in fantastic shape and runs great (though only gets about 20MPG). Owned van for 2 months and have driven about 7,000 miles. 1st problem I've encountered (other than a very uncomfortable drivers seat - feels like a spring is sprung!)
View 14 Replies
Advertisement
Working on a 2001 caravan. Been sitting for about 6 months with no battery installed. decided to work on it. Got a new battery, and when I connected it the alarm went off. I dont have panic button for it so I unhooked the bat.
I think I hooked the bat back up with the thicker gray key in the ignition. I think that is the key with the chip.
The alarm did not sound but the engine will not crank, seems like it it in some security mode blocking start up. I tried cycling the key in the driver door but that did not work.
View 1 Replies
Vehicle: 2003 Dodge Grand Caravan 3.3 Litre
I also have my CE light on. Hooked up my reader and got the "P1491 Radiator Fan Control Relay" code. I have checked my rad fan fuse and it is okay. My attempt to locate the rad fan relay took me from the rad fan wire to a device that looks like a heat sink. It is located on the vehicle frame between the rad. and front grill. Is this the rad fan relay? If it is I'm not sure how I would replace it. It seems riveted to the frame.
View 7 Replies
I've been fighting with these vehicle for months, and I've only been able to narrow down the list of possible issues. Tried replacing the ignition switch, battery terminals and cables, starter, and even a PCM since according to the dealership it was bad. I've checked all the fuses and relays, and they're all ok.
I'm getting fuel and spark, but no crank from the starter. The voltage going to the hot post on the starter is 12.7, but the voltage from the igniton wire is only reading around .5-.6, fluctuating a bit. Before I spend the money on taking it to a mechanic I wanted to know what your opinions were on what the next step is. I know a bit about electrical systems in cars but I'm no expert.
View 3 Replies
I was riding down the interstate this morning and had my cruise control set at 70mph. all of a sudden the cruise just turn off. I went to hit the gas pedal and there was nothing. No check engine light or anything, no spit, no sputter. I pulled off the side of the interstate and attempted to start the van. the engine turns over fine, but no start. all lights, radio work fine. car has fuel. it did not run hot.
View 1 Replies
I have a 2003 Grand Caravan, 3.3L, 75,000 miles. The van suddenly will not attempt to start. The strange thing is that when the key is turned to RUN I cannot hear the fuel pump. The normal 2 or so second on growl at the initial key turn is not there. When turned to start the clock on the radio goes out and no crank. I have found that the start relay is not passing on the signal to the starter. If I jump across the two pins going to the starter, the starter cranks fine. The van will still not start because I believe it has no fuel,due to the fuel pump not running. I thought first that it must be the neutral safety switch but does that have any control of the fuel pump also? I have found that the neutral safety switch requires that I remove the valve body for access.
View 14 Replies
I have a 99 Voyager with 88,000 miles. Brand new battery 12/12/06- won't start 3 weeks later - cleaned & protected battery connectors - still no start if left for more then 4 hours undriven Battery tested fine- being drained approx 2 amps- something left on...? Now there is a clicking sound under the dash before trying to start. Could it be some type of relay being left open or fuse or
View 6 Replies
I have a 99' GC and just changed out the EGR valve. Now the engine cuts out when you brake or get to a low speed. Idles a little rough also.
View 7 Replies
I have an 2002 Dodge Grand Caravan that cut off shortly after starting the other night. Every time I try to start it, it will crank and then stall almost immediately. I tested the fuel pressure and it was strong so I hooked up a pocketscan and my van starts and runs normally while the pocketscan is hooked up. I even took it for a drive around the neighborhood. As soon as I unplug the pocketscan my engine shuts off. The only code on the scanner was for the O2 sensor(not something that would shut my engine off.)
View 1 Replies
Issue on grand caravan 1996 happen, while driving all one time I hearing a clicking noise inside dashboard and abs+airbag and weather control, they stopped to work all in one shot .
View 1 Replies
Service Engine light came on couple days later turned off, came back on today & vehicle stopped shifting into 3rd. Later this evening was driving it and power steering went out, ABS light came on, temp gauge jumping from hot then cold. When Service Engine light came on originally took to autozone. these are the codes given:
P0700
P1776
P0420
I have read problem could be input or output sensor which are $17 bucks each. Going to try those...
Mileage is 145,000
View 4 Replies
I have an 02 F250 6.8 with 51,000 miles on it. I recently replaced the battery about a week ago, and only actually drove it yesterday for the first time since replacing the battery. I drove it about 25 miles, parked, and when I went to restart, it wouldn't. The starter doesn't crank, so I mean its not a cranking issue as in cranking, and not starting. It only clicks at the relay when turning the key. It acts like when you try to use a wrong chip coded key.
All of the dash lights came on, and I can hear the relay clicking, but that's it. I swapped the relays around, and no luck. If I let it sit a while, about an hour, it will fire right up. The battery cables are tight and free of corrosion. I am curious, since I just put in a new battery, could this be the culprit? Why will it start fine cold, but not hot? I have NEVER had an issue with this truck until now.
View 14 Replies
Alright so I have a 99 7.3l. One day I went to start my truck and when I turn the key to the on position all is normal and then when I turn it all the way to crank it nothing happens. I hear a relay click ann thed that's it. Me and a buddy of mine spent quite some time on going through the entire truck. The starter was replaced, the neutral safety switch was replaced and the ignition switch was replaced yet the problem is still there. We then discovered that fuse #20 under the dash keeps blowing with every turn of the key. The manual states that this fuse is a starter motor relay coil PCM ( gasoline only). So if it's gas only why is it even in there. Let me just say that I can jump the fender mounted relay and the truck starts.
View 7 Replies
My neighbors 02 250 6.8l the turn signal/hazard relay is clicking with key off, sounds exactly like a turn signal when truck is off and switches are not engaged. Here's the weird thing, if you hit the brakes the relay stops clicking, if you engage the turn signal or the hazards the lights on the dash are in time with the relay as it should be, but when the turn signal switch or hazards are turned off the relay keeps clicking except when you hit the brakes. Also the turn signal will work with ignition off, if you pull the relay out the turn signals and hazards are inoperable but the brake lights still work. I swapped in a new relay and same thing...
View 8 Replies
My right front brake caliper is frozen and I cannot turn the tire. This happened about a month ago and I went to Autozone and they gave me a new caliper, rotor and brakes, under warranty, and now the caliper is frozen again and I cannot turn the tire when jacked up. It seems to release after a period of time. I am not sure if it has a proportioning valve for the front brakes, but the driver side wheel turns freely and is not stuck.
View 2 Replies
We have a 96 t&c. The turn signals only work once in a while. Sometimes they start to work and then freeze. Sometimes they don't work at the beginning of a ride and start to work 10 minutes into it. It seems quite random.
View 14 Replies
2007 Grand Caravan SXT, 86K Miles
Factory Radio Clock, AM/FM, CD and Tape Player.
Radio and Clock looses power and completely shuts off and will not turn back on while driving. Miles driven does not seem to be consistent.
All other Electrical seems to work fine, overhead console, Wipers, Blower, Turn Signals, Head Lights, Instrument Panel all seems fine.
When car is shut off, Blower continues to run for a few seconds and then stops.
When car is restarted Radio/Clock magically comes back, clock is reset to 12:00 and radio is on AM.
Get some funny flashing of Idiot lights on cluster that to my recolection is not normal behavior. Once while my wife was driving it the Vehicle Theft Alarm Light came on when she started it up and it stayed on until she stopped and then started it back up when she left the store she was at. That has only happened once.
I checked the Battery Voltage while running and stopped and all seems normal. The Battery was new this December. I also checked fuses and there are none that are blown.
View 1 Replies
This has happened twice now. I went to turn a tight corner and the power steering just went out. A moment or so later, it came back. Any conjecture?
View 3 Replies
I have a 2000 Dodge Grand Caravan that has 195,000 miles. My radiator fan won't turn on and I'm stumped! The issue presented itself with a check engine light and the radiator cooling fan not turning on. The trouble code indicated the cooling fan relay was faulty. In all cases below, I tested the radiator fan by turning on the air conditioning (thus forcing the cooling fans to run) and also for it to come up to a high temperature coming close to the danger zone.
1. Fuse - first tested the fuse and it was OK. Had to start with simple things first.
2. Cooling fan relay - I replaced the relay which has a reputation for failing on the Dodge. Still the fan did not kick in.
3. Cooling fans - tested the cooling fans and the motor was seized. Replaced the cooling fans and tested them by jumping them. The cooling fans still do not turn on. There is no voltage leaving the cooling fan relay and coming into the cooling fan harness.
4. Wiring - tested the wiring between the relay and the fans. They checked out OK (good continuity and resistance check). There is no voltage leaving the cooling fan relay. Now it's getting more complicated... I unplugged the wiring harness from the ECM and tested the wiring between the ECM and the cooling fan relay. A-OK.
5. ECM - it is unclear how to check the ECM for functionality of the cooling fan.
There are 3 wires (supply, ground, and switch wire?) The supply voltage and ground is good, but I don't know what voltage the switch wire should be. I've read that it is pulse width modulated so I can't measure this with a simple voltmeter. I've also read that the switch wire goes to ground thus triggering the relay. I don't know which is correct. Several mechanics I talked to were skeptical that the issue is with the ECM, they knew of very few instances of this being the culprit. I even replaced the new cooling fan relay with another new cooling fan relay on the off chance that the replacement was faulty. Did I miss something in my logic and diagnostics? I've resorted to wiring a switch directly to the cooling fans and toggling them on and off.
View 4 Replies
I have a 98 f150 Lariat 4wd Automatic with a 2000 4.6. When i turn the key the only thing that happens is i hear a relay in the fusebox in the dash clicking. I can cross the starter relay on the firewall with a screwdriver and itll start right up. Heres what ive done troubleshooting wise.
1. Checked battery terminals. Fine, it will start with jumping the relay so it seems good with that regard.
2. Tested the relay per the manual. Good.
3.Ohms Tested the white ignition switch box under the dash per manual. Good
4. Voltage tested the Trans Range Sensor per manual. Good.
5. Checked over all fuses, none blown.
6. No theft lights come on.
I figure since it will start jumping the relay that the battery, starter, and starter solenoid are all good. Only thing i cant seem to find is the Starter Interrupt Relay, or any sign of fusible links on the main battery cables. I am really at a loss here i figured one of the components ive tested would be it.
View 14 Replies
2000 excursion V-10. I parked the truck, went back to start it and all my gauges blink, and the number one relay under the dash (interior light relay) begins clicking. The truck will not even crank. The relay will continue clicking (even with the key off) until you remove and replace the relay. Sometimes I will get absolutely nothing when I turn the key. I have tried jumping the battery, no change. Also tried starting it in neutral to trouble shoot the NSS, but it won't even click when in neutral. I checked battery connection, and followed the battery cables to look for a short but found nothing.
View 3 Replies
