Caravan/Voyager :: 1990 V6 - No Power To The Fuel Pump?
Jan 19, 2005
I have 1990 dodge caravan v6, i checked to see if i got power to the fuel pump and there no power going
View 4 Replies
Jan 19, 2005
Advertisement
Caravan/Voyager :: Power Steering Pump Not In Line 2000 Grand 3.3?
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
Caravan/Voyager :: 1990 - Serpentine Belt Comes Off In Rain
1990 Dodge Caravan ... I replaced belt, idler pulley, tensioner pulley. The serpentine belt comes off when it rains.
View 9 RepliesCaravan/Voyager :: 2006 - Engine Light Is On After Water Pump Replacement
I had to replace the water pump on my dodge Grand Caravan, which was challenging, but I got it done. But now the engine light is on.... why would that happen? I did take off the filter hose, and unplugged the cord to move the air filter housing, but I plugged it back in when i re-hooked everything up. So now I am nervous that i did something wrong. Why the engine light would come on and stay on? water pump works, put coolant in etc.... no leaks.... so now i just need to figure out the engine light.
View 9 RepliesCaravan/Voyager :: 1999 Cannot Get Started - No Pressure On Fuel Rail
A friend has a 1999 Caravan with the 3.0L engine. He couldn't get it to start and to make a long story short, I checked the fuel pump relay and fuse and they were good but there was no pressure on the fuel rail. Turning the key I couldn't here the fuel pump come on and determined the fuel pump was bad.
I changed the fuel pump and fuel filter put in 1/4 tank of gas and turned the key, and it turned over but wouldn't start. I can audibly hear the fuel pump come on for a second or so, and feel the vibration when I put my hand on it, but there is still no pressure at the fuel rail.
Caravan/Voyager :: 993 Dodge Grand - Small Leak Found In Fuel Rail
I have a 1993 Dodge Grand Caravan. I found a small leak in my fuel rail. Can I buy a repair kit for this or do I need to find a new fuel rail? If so where to find a rail for a van this old?
View 2 RepliesCaravan/Voyager :: 1993 Dodge Grand Van Not Properly Burning Fuel - White Smoke Coming From Exhaust Pipe
My van has quit me finally. It only has 98,000 original miles on it. Right now the car really smells like it is loading up and not properly burning fuel. Also a huge amount of white smoke is coming from the exhaust pipe. The oil pressure is good. could it be as simple as new plugs and plug wires, coil pack etc.
View 3 RepliesCaravan/Voyager :: Catalytic Converter Getting Red Hot And No Power?
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 RepliesDodge - D150 :: 1990 - New Fuel Pump Wasn't Grounded
1990 Dodge Ram Van.... How hard is this to fix. Some Guys in Los Banos took two days to replace a fuel pump. End result, new pump not grounded so continually drains battery unless I mess with a fuse everytime I start/stop car.
View 2 RepliesCaravan/Voyager :: 98 - Power Locks Keeping Locking Every 30 Seconds When Off
When it is off, the power locks keep locking every 30 seconds!
View 4 RepliesCaravan/Voyager :: Power Steering Went Out Temporarily When Turn A Tight Corner
This has happened twice now. I went to turn a tight corner and the power steering just went out. A moment or so later, it came back. Any conjecture?
View 3 RepliesCaravan/Voyager :: 2000 - Power Lock Switches Aren't Working
I have a 2000 Dodge Caravan. The power lock switches are no longer working (both driver and front passenger). They worked fine the last time I drove the vehicle and both switches stopped working at the same time. The power locks themselves still function with the remote and still lock when speed reaches 25km. Just the actual switches on the doors are not functioning.
View 5 RepliesFord Super Duty (1999-2016) :: 1990 - Way To Replace Fuel Pump?
Will it be easier for me to drop the tank or to take off the bed of the truck does a 1990 F350 7.5 liter dual tank gas
View 1 RepliesCaravan/Voyager :: 1994 Vehicle Stops / Sputters To No Power - Could Be Vapor Lock?
I have a rather peculiar problem with My 1994 Dodge Grand Caravan 3.3L. This has happened multiple times spread out over the last 10 years. Every couple of years after a rather long drive, then a stop, it spits, sputters, has very little to no power, and will ultimately die. It will usually start right back up, idle fine, but when you shift into gear, it acts up as described. If you let it set for about 15-20 minutes, it will usually start up and run fine without the symptoms as described.
The First time it happened I was lucky enough to be within a mile of the dealer, who diagnosed a bad fuel pump before it was ever on the lift. He showed me what he said was the culprit, which was a fuel filter that was full of black particles and soot. He replaced both the pump and filter and it ran fine for a couple of years and it started doing the same thing. Another new fuel pump and filter and we're running again (all under warranty).
About three years ago it did it again and this time we went to a different dealer and since we were no longer under warranty, we wanted to know what was actually going wrong. Nothing was ever found, no codes, pressure was good, everything looked fine. No problems until today when it started again, no dash or check engine lights, it just wouldn't run. We let it sit for 20-30 minutes and started it right up and drove it home without incident.
Are these vehicles known for vapor locking? It sure acts like that is what it was doing. The temp wasn't that hot and was ruled out as a factor.
I am planning to put a new fuel filter in it?
Caravan/Voyager :: 2004 Dodge Lost Power To Windshield Washer Motor And Headlights
My 2004 Caravan lost power to windshield washer motor and headlights, after checking under fuse box, I swapped over the relay marked headlights washer , still nothing. I disconnected the power module at the front of the fuse box by removing four torx head screws. Removed it by rocking it a it out towards the front of the van. I cleaned the terminals and replaced it. Seems to have solved the problem .
View 1 RepliesFord 6.7L Power Stroke Diesel :: Whining Sound / Low Fuel Pressure And Reduced Power Warning - Fuel Pump Just Died
So, I just had the fuel pump replaced on my '15 6.7 a month ago and it just died again. (next day edit: it didn't actually die, it showed all the same symptoms)
Same symptoms: whining sound, low fuel pressure warning, reduced power warning.
This time I'm 50 miles from home so I pulled off the road before it shut off. Interesting, I was in a hilly area and my low fuel warning came on too. We are waiting for a tow. I was considering trying to push on but don't want to get stuck in a dangerous spot on the highway. We're in a church parking lot.
So, last time this happened I was on flat road with about a half tank of fuel on a lunch break. I ran a mile after the warnings came on to feel out the issue and to see what would happen. I happened to be only about a mile away from my dealer so I drove that way. I got reduced power warning and then it cut power on me (limp mode). I made it to about 100 yards away before it cut off.
This time, I was in a hilly area at night on a windy two lane road with no shoulders in the woods. I was miles from civilization and was showing below a quarter tank of fuel. ~100 miles to EMPTY. I got the low fuel pressure warning first and then the reduced power mode before the whining noise started. I was climbing a hill on a curve at the time. I drove a quarter mile and then pulled off the road into a parking lot so I wouldn't be stuck on the shoulder. It didn't actually go into limp mode.
I let it sit a few minutes, talked it over with the wife and decided to call for a tow. After talking to the tow truck driver who said he would be an hour because he had to go find a bigger truck, I decided to see what I could do while I wait. I fired it back up and the fuel level dropped to below 1/8 and I was now showing 33 miles to EMPTY. I was parked on a hill with the back end up. I had backed the truck into a space to make it easier for the tow truck driver. I let it run a minute, checked for leaks and it seemed to run fine with no studdering or additional warning lights.
CEL was on but no new warnings. I put in my code reader and pulled the P0087. Just one code. I revved it a bit to see if there were any issues. It seemed fine so I decided to try my luck. I started driving towards home with the intention to stop at the first diesel station to fill up. Truck ran fine. After two minutes of driving gently, heart racing, my fuel level came back up and it now read 88 miles to EMPTY. I drove 11 miles to the nearest station and filled up. No issues. I shut it down. I fired it back up. Still no issues so with a full tank, I drove home the remaining 30 miles without issue.
Planning to take it in to the dealer Monday to get it checked. Could this be from an air pocked due to low fuel level and hilly terrain? Is my new pump dying already? Is there something else going on inside the tank or elsewhere?
Caravan/Voyager :: 2012 - Programming New Key
We just purchased a 2012 Grand Caravan and was wondering where to get a key and program it. I know the key will be an arm and a leg if i get it from the dealer. Is there a tutorial that tells how to program it as well?
View 3 RepliesCaravan/Voyager :: Heat Comes And Goes Every Minute Or So
2006 Caravan. Heat comes and goes every minute or so. Also noticed the temp gauge goes from normal operating range to cold and back again frequently. Hasn't overheated. Does that sound like a thermostat problem?
View 2 RepliesCaravan/Voyager :: ABS Light Keep Coming On
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
Plymouth :: 1991 Grand Voyager Loose Power As If Not Getting Fuel
I have a 1991 Grand Voyager 3.3liter AWD minivan. It only has 80k original miles on it. It works totally fine sometimes, and then for no apparent reason, begins to lose power, as if it's not getting fuel. I can put my foot into the accelerator hard and it will likely correct itself in a few miles. If the cruise control is on, it will lose power...then regain it....then lose it....and so on, for many miles. The problem does not happen every time I drive, but most times. I have changed the fuel pump twice. each time it seemed fixed, but then the problem comes back. Most recently, It quit altogether, and I had to be towed home. I can start it now with starting fluid, but i suspect the fuel pump is out again. Another strange aspect of the problem is that this is my 2nd 1991 voyager, and the first had the same identical problems. I use it as a delivery van, and need to get it reliable...I've considered the ASD relay, or the fuel pump relay. I changed the fuel filter today to no avail. It currently won't start without ether.
View 4 RepliesCaravan/Voyager :: 05 - Clunk In Front End When Hit Bumps
What am i missing i have a terrible clunk in the front end when i hit bumps. I thought it was the struts and mounting plates so they are new . no change Stabilizer links were tight but i replaced them as well. Everything else seems tight but the noise has not changed with any of the above mentioned repairs.
View 13 Replies