4Runner/GX470 :: 1997 - Rear Differential Clunking Noise
Aug 7, 2012
I brought my 4runner in to fix a rear axle seal and to see if they could isolate a clunking noise I've been having. They said the clunking was coming from the rear differential (I believe him as that's what I heard, while driving or even just putting it into gear). They have yet to call me back, but any guesses here as to whether it is a bearing (my guess, as it is most pronounced on a bumpy road) or a cracked gear or something else. I've been driving with a clunk for about a week, but have various clunk problems for the last 80k miles ....
View 14 Replies
Advertisement
I've had this problem for years but is now getting worse. It used to only happen when it was really cold out, subzero, but is now happening as we now approach 50 degrees out. If I hit a pothole or pop over a small curb, I get a clunk in the rear. I replaced the shocks about 3 months ago which seemed to work briefly but the problem is back and is worse than ever.
I have the original springs and it looks like the recall was done by the previous owner (rubber bumber stops installed).
230k miles. Do I need new springs?
View 13 Replies
I've noticed that my brakes are very sensitive lately. I'm wondering if it has anything to do with the differential oil that got on the rear pads when the rear seals blew out about 3 months ago. The shop cleaned them off but they still looked oily to me. I'm also wondering if it is parking brake related as one or both of the bellcranks are frozen (there's no cable sag, but one of the stops has a gap and the parking brake doesn't work). Or is it brake fluid related. I am years past the point of needing to replace the brake fluid and bleeding out the old fluid.
View 5 Replies
I just did my winter hard top for the season, hooked up the plug for the rear heater and it works but it's cranking out cold air even when I am up to running temperature. The front heater is blowing lots of heat. Am I missing something? Is there something other than the plug I need to hook up?
View 12 Replies
This 96 4 runner's rear wiper and rear window has stopped working. I can only assume they stopped at the same time as the truck doesn't belong to me, I was just asked to see what it would take to fix it. I've looked it over and see no fuse and don't really have a clue where to start looking for the culprit of the problem.
View 2 Replies
Starts humming at around 25mph and gets louder and higher pitched as I accelerate. Noise stops when I turn right so I assumed it was the right rear wheel bearing. I replaced the hub bearing and the noise continues. Also had the tires checked out and they seem to be fine.
View 1 Replies
I have a 97 4runner Automatic that as your driving it hesitates between shifting its gears. Most prominently happens around 80km/hr shifting between gears.
Its a sort of soft sputtering/jerking motion momentarily. It does shift into the gear and does drive fine once its in the gear. My check engine light is on as well now....
View 5 Replies
I just came back from a long trip and during the 400 miles drive I started to hear noise coming from my differential - kind of like a constant high gear loud noise. I will hear this noise when I start to accelerate and it will only gets louder and louder as I go faster and faster. I had a pinion seal leaked fixed last week and I checked the fluid and it is full.
View 9 Replies
I have a 2001 Toyota 4Runner SR5 with AT and V6 with 70k miles on it with pretty much everything loaded. The car has been trouble free since I got it 3 months ago. However,the past month, the engine has been making a high pitched "squeaking" noise whenever im at a constant speed. If I accelerate or brake, the noise goes away.
I also noticed today that it stays constant no matter what when I am in 4WD mode, but when I am in 2WD it behaviors like I describe earlier. I had the Toyota dealership do a complete lube service and they found two of the belts were "dry" and re-lubricated them however the problem persisted. The noise doesn't happen when im in idle or at a stop either. The noise seems to emanate from the right side of the engine.
Also, do 4Runners have a noisy brake cylinder system? Almost every time I brake I hear this slight "Pssssssssssssssssssss Tick!" sound from the engine. The car brakes just fine and the Toyota dealership found nothing out of the ordinary but i've never heard a car break that noisey before. This a 4Runner trait? What could be causing these two noises, especially the gawd awful squeaking noise from the engine. It never made that noise until just one day..
View 6 Replies
My 1997 4.0 Rear Wheel Drive is making a clicking noise when it is put into gear or when it switches from drive to reverse and vice versa. Sound is coming from the back of van. Does not make noise all the time. Drove 50 miles last night with no problems and minimal clicking. Could it be U-Joints going bad? Or is this a different problem?
View 6 Replies
Here' the low down. I have a 90 4runner v6 4wd. It is intermittently making a loud rubbing noise in the front right of the truck. It starts randomly and sometimes stops on its own or will start when I hit a bump,it will stop when shifted into 4wd, or when I brake or turn hard to the right. but happens only a portion of the time. took it to mech, he removed front drive shaft and said prob went away, it seemed the vacuum pump or the solenoid that activates shifting out of 4wd is defective. So he manually switched off the 4wd replaced the front shaft and all good! but on my way home the noise began again. super frustrated, 3rd mechanic in a week.
View 1 Replies
I have an 1990 Toyota 4Runner. V6 engine. Automatic. 4wd. Today it blew an upper radiator hose. A few seconds after the initial pop of the hose and the spew of fluids the vehicle died. I replaced the upper radiator hose and the lower hose- and refilled the antifreeze. There are no leaks as of right now.
The engine will not start. The belts spin whenever the key is turned on. But the engine will not crank. You can hear the starter trying to start it up. Jumping the vehicle was of no luck. Charging the battery was of no dice.
The vehicle makes a whirring noise (belts spinning) when key is turned, but the engine does not crank at all. The noise stops as soon as you shut the key off. The oil is clean and full still.
View 2 Replies
Last week I broke the pinion and spider gears in in rear end. Well Im getting a used rear end rather than rebuidling mine. What is the gear ratio on the 97 F150 xlt 4.6l 4x4. I figured they would all be the same but my tag is missing on my diff and I was told by an auto parts store that there were a couple different ones.
View 14 Replies
My rear-end differential came apart and is not repairable. I have a 1997 F150, 2WD, 4.6L engine, 5 lug wheels. Which years have the same rear ends so I can scour the junk yards for a replacement?
View 4 Replies
Any likely culprits? 2002 F150 (with Triton V8 if that makes a difference).
View 4 Replies
Well i picked up a 96 4x4 with the 4.0 a few weeks ago and been fixing stuff weekly that i find wrong. One thing i noticed was the rear diff was leaky but couldn't get the fill plug out so left if for now. Last night my wife was on interstate and it just started making a loud noise so she pulls over calls me. I get there and drive it and it makes a woowoowoo noise and it got louder as speed increased. She was 3 miles from the exit so i drove it about 15-20 to get it off interstate than another 2 miles to her sisters. We let it sit for a few hours and found a flatbed to haul it home, and when we finally got home i drove it off the flat bed and now it was making a loud clunky noise. Parked it in drive till today. Cracked open the rear and no fluid came out.
Inspecting all the gears looked good no metal in bottom so i went and got a new rear cover and 3 qt. of fluid. Put it back together and the woowoowoo was still there but seemed to slowly go away as i drove it around the block. So what else could be going on here or do i need to drive it and warm up the fluid so it circulates? I also noticed a sheeee sound like metal on metal when braking but i changed all 4 rotors and both pads last week but i noticed the brakes in the rear that look like drum brakes was bare but i assume that is only for the ebrake so didn't bother changing them yet. Could those be hitting the inside of the rotor and making the metal to metal noise?
View 14 Replies
I have a 92 4runner with v6 5speed Manual tranny it has the A.D.D hubs ,when I put it in 4wd its not going into 4wd the 4wd indicator in dash is not coming on ,that could be a bad bulb cause it doesn't come on when you turn key on.The transfer case is working all right .Its something in the front end that's not engaging .I noticed on the front diff. there is some kind of solenoid there with vacuum hoses and a electrical connection .Does this have anything to do with it not locking into 4wd?
View 2 Replies
on a 93' 4 runner that will not engage 4 wheel drive. The 4 wheel manual shifter works fine, and the linkage underneath looks fine; however, the indicator does not light up - and it definately only has rear wheel drive.
View 5 Replies
I have a problem with my 4runner, it ran good when I drove it before I deployed, not I got back and it will not run, it starts for about 30 seconds then dies, sounds like something is killing the fuel, I took the cap off the tank to see if it was clogged, but thats not the problem, it just will not stay running for longer than 30 seconds. Also I realized that the alternator was very hot for the 5-7 times I started it and had it run for 30 seconds? Oh it's a V6 3.0L 5SPD manual 4X4 by the way.
View 3 Replies
we have just pulled out head resurfaced and put engine back together now it won't start tried the timing and checked for fuel but wont start the only way it starts now is with brake fluid in the intake but that only fires up and won't stay idle.
View 3 Replies
The transmission went out on my toyota 4 runner ...
View 1 Replies
